Académique Documents
Professionnel Documents
Culture Documents
First, make sure necessary server BIOS and hard disk RAID configuration are completed, then start to install SW. Please choose boot from CDROM in HW BIOS. The following screenshot is the first prompt after entering CDROM boot up, as seen in PIC 1.
PIC 1
Press Enter to continue installation. Additional driver need to be installed by expert disk command if hard disk cannot be recognized. System will ask to choose other disk (can be floppy drive or removable disk containing diver image) to install driver.
Second prompt screenshot: as seen in PIC 2, select Skip to bypass CD verification.
PIC 2
PIC 3
PIC 4
PIC 5
If its fresh hard disk, the following prompt will be shown as seen in PIC 6, press Yes
PIC 7
System partitions hard disk automatically, no artificial action needed as seen in PIC 8
Pic 8
As seen in PIC 10, after SW installation system will ask you to restart, at the same time please insert valid USB-KEY to make sure SW startup properly.
PIC 10
You have finished SW installation successfully. Please take out installation CD from CDROM before reboot and then press enter to reboot system.
SW Configuration Notice
After previous SW and HW installation steps, YES has been successfully installed. You can start to configure based on actual need after server restarted.
After enter environment configuration page, please finish license register firstly. A successful register page as seen in PIC 11:
PIC 11
After successful register, please contact with StreamOcean Engineer who will do the further configuration.
Hi Van - Since it's the first time we support Dell M1000e blade, we met the raid controller's compatibility issue, DEV team prepared another ISO for your blade server, please download it : http://123.30.191.151:8080/SO-StreamSense-3.4.0-x86_64.iso; - Tip:when the screen prompt installation mode, please type "ks" for two disks(two raid)(VOD-EDGE and sanity server should be this type) type "kssmall" for less than 1T single disk(one raid).(LIVE-EDGE and CCG can be this type) type "kslarge" for larger than 1T single disk(one raid) - After installation of system please setup public ip and mail to me for the further configuration.