Académique Documents
Professionnel Documents
Culture Documents
Assumes limit switches are not installed on your machine. Step 1. Disable input switches except the E-stop switch Navigate to Ports and Pins
Input these numbers into the table. These will act as preliminary settings that will later be optimized.
Do not change your polarity settings, but copy all of the other settings in this table
You do not need to change these settings, either (home neg and auto zero)
Still on Mach3..
Click on Ref All Home Values in X,Y,Z will show 0 afterward. Your machine should not move.
Click on Ref All Home
No, go to your mini mill again.. Jog your machine to any location within the working envelope: Make it at least 2 inches from any hard stop.
Still on Mach3..
Click on Soft Limits to enable. A green border will appear around the switch (the green border does not show in the photo, but it will on your system if you are connected to your machine). Your soft limits are now enabled.