Académique Documents
Professionnel Documents
Culture Documents
jm-Sept 05
XTR
XTR
Sensor
Sensor Signal Conditioning Signal Converter and Supply
Supply Voltage VS
RCV2
RCV n
3
jm-Sept 05
XTR
Power supply for the XTR and the Sensor is derived from the minimum current <4mA (<3.4mA) and the sub-regulated supply voltage.
jm-Sept 05 4
XTR
Error Signaling Range: 3.4 to 4mA and 20 to 24mA These under and over ranges are used to indicate error conditions of the sensor: wire break, short, over-load, excitation failure. There is a NAMUR specification, which specifies these special ranges.
jm-Sept 05
XTR
Power dissipation of the XTR is calculated from the voltage across the XTR and the current flowing. Examples: 24Vsupply (20mA*500W) = 14V
P = 14V * 20mA = 280mW 36Vsupply (20mA*50W) = 35V P = 35V * 20mA = 700mW
We use an external power transistor to get the heat out of the IC.
jm-Sept 05 6
4 to 20mA Current Loop Circuit Protection Protection against harsh industrial environment:
+ Supply XTR Signal Out
XTR
jm-Sept 05
XTR
XTR
HART is a digital protocol which can be modulated onto the 4 to 20mA signal wires. It is used where remote sensor programming is required (Smart Sensor) HART puts several restrictions to the wiring, wire length, shunt resistance and supply voltage.
jm-Sept 05 9
3-Wire Connection
XTR
Sensor Sensor Signal Conditioning Signal Converter (and Supply)
Signal Receiver
jm-Sept 05
12
XTR
Popular signals for these active sensors are: V 0 to +10V, 0 to +5V I 0 to +20mA ( 24mA ), 4 to 20mA ( 3.4 to 24mA ) The current signal is compatible to the 4 to 20mA current loop signals.
jm-Sept 05
13
XTR
Reg. Out
DRV
I-Mirror
Output Failure
SENSE
+ VREF
Signal Input
I1
IOUT
0 to 20mA (4 to 20mA)
GND
External Resistor R1 allows flexible setup to a wide range of output currents. Supply max : 44V, nominal: 24V. Supply min: < 9V Current compliance stretches well below GND ( external transistor) I1 defined by ext. R1. I2 = 10 * I1 Regulator output: <5mA Package: DFN-10 [3x3mm] Internet Price: $1.45 (@1kpcs) RTM: Q2 2006
14
jm-Sept 05
XTR
(PGA309 ...)
Sensor
Sensor Signal Conditioning
+ OPA -
Signal
R2 1k R1 1k
jm-Sept 05
16
XTR
(PGA309 ...)
Sensor
Sensor Signal Conditioning
jm-Sept 05
17
tg-Sept 05
Input Signals & Feedback Voltage, VR2, referenced to Iret Feedback Voltage, VR2 is negative with reference to Iret Op Amp Circuit Loop Gain forces A1+ = A1- = Iret = 0V IIN = VIN / RIN + Vref / Roffset IR1 = IIN IIN * R1 = VR2 VR2 = Iout / R2, Op Amp Loop Controls Iout to Create VR2 Iout = VR2 /R2
18
Current cannot flow through R2 in the right direction to create 0V at A1+ (Need VR2 to be negative referenced to Iret) T1 drives current into ground at Iout over-current limit of 41mA tg-Sept 05 though RL !! No current
19
tg-Sept 05
20
XTR115
VREF=2.5V
4-20
5V@4mA
SOIC-8
0.95
XTR116
VREF=4.096V
4-20
5V@4mA
SOIC-8
0.95
tg-Sept 05
21
XTR115 / XTR116
tg-Sept 05
22
XTR110
VREF=10V
13.5 to 40
---
DIP-16
6.35
XTR110
tg-Sept 05
23
RCV420
VREF=10V
4-20
0-5V
---
DIP-16
3.34
tg-Sept 05
24
1k RTD Conditioner
10k RTD Conditioner
7.5 to 36
7.5 to 36
DIP-14 SOIC-14
DIP-14 SOIC-14
tg-Sept 05
25
tg-Sept 05
26
2-Wire RTD Conditioner with Digital Cal for Linearization, Span, Offset
Device Description 100 to 1k RTD Conditioner w/6-Channel Input Mux. Extra Op Amp can convert to Voltage Sensor Excitation. Sensor Excitation Loop Voltage (V) Full-Scale Input Range Output Range (mA) Additional Power Available Package Price 1k $USD
XTR108
7.5 to 24
5mV to 320mV
4-20
5.1V @ 2.1mA
SSOP-24
3.75
tg-Sept 05
27
tg-Sept 05
28
tg-Sept 05
29
Programming Board
Transmitter Board
Evaluate XTR108 with your RTD Software Calibration/Control for XTR108 Available NOW!
tg-Sept 05 31
VOUT
See NEW data sheet for details (page25)
jm-Sept 05 32
VREG
XTR117
Pressure Transducers Temperature Transducers Humidity Transducers Industrial Process Monitors PGA309 4-20mA Output Converter (Convert Voltage-Out to Current-Out)
V+
+5V
Linear SubReg
RIN
IIN A1
RL
IRET IOUT
tg-Sept 05
33
&
VREG
XTR117
XTR117
+5V Linear SubReg V+
P
psi
Non-Linear
50
PGA309
VEXC -
Ref Ref
Bridge Transducer
Fault Fault Monitor Monitor
Linearization DAC
RIN
IIN A1
Linear VOUT
VIN RL
IRET
IOUT
Ext Temp
tg-Sept 05
34