Académique Documents
Professionnel Documents
Culture Documents
Model materials
Materials with high and low elastic modulus Poissons ratio Creep and thermal conductivity Workability When there is complex geometry and irregular shape, an easily workable material will be the choice. For shape models a good workable material which can with stand the prolonged exposure to water is preferred.
Metals
High accuracy Satisfies most of the model requirements Easily workable and available in various shapes and forms Aluminium or its alloys are preferred Best material for hydrodynamic models, if weight distribution can be satisfied
Plastics
Derived by chemical synthesis-contains carbon compounds Thermoplastics-becomes softer beyond glass transition temperature-can be formed in to complex shapes and geometries-retains shape on cooling-a good mould is required-examples are acrylic resins (perspex) and poly vinyl chloride (pvc)-available in sheets, tubes, rodscan be machined and joined
Plastics
Thermosetting plastics-usually cast into shape-accurate moulds are requiredphysical properties can be changes by using suitable fillers-Epoxies are typical examples. Fiber reinforced plastics-used in making very complex models Plastics are viscoelastic materials. Care must be taken in strain measurements
Wood
Ideally suited for shape models being workable Absorbs moisture Wax coating or suitable epoxy coating is used to prevent water ingression
Polyurethane Foam
Can be easily finished to the required shape and sizes. Available in slabs-can be machined like any other material When used in water it requires surface treatment to prevent water ingression
Fiberglass models
Preparation of accurate mould Fiberglass is applied on the mould by hand layup Several layers of fiberglass may be required for the required strength. Each layer is coated with binder usually an epoxy Mould is made by spraying polyurethane foam to the prepared skeleton of templates Excess form is removed till the edge of the templates are visible
Plastic Models
By joining machined components Joining is done by capillary welding or using glues and adhesives Plastic welding Thermal forming of plastics Drape moulding