Académique Documents
Professionnel Documents
Culture Documents
SOLAR ENERGY
A FEW FACTS Every day the earth receives thousands of times more energy from the sun than is consumed in all other resources. If a 140x140 mile parcel of land in Arizona was covered with solar cells, the electricity needs of the entire United States could be met. The sunlight falling on a typical house can provide from 1/3 to 1/2 of the heating needs of that house. Today solar energy accounts for only 1% of the total renewable energy consumed in the United States
Characteristics of Isolation
Isolation is the amount of solar radiation reaching the earth. Also called Incident Solar Radiation. The suns energy is created from the fusion of hydrogen nuclei into helium nuclei. Components of Solar Radiation: Direct radiation Diffuse radiation Reflect radiation
THERMOSIPHEN
This method places the storage tank above the solar collector. Cold water is put into the bottom of the storage tank where it is circulated through a flat plate collector and pumped back into the top of the storage tank. The heated water can then be taken from the top and used.
ATTACHED GREENHOUSE
Uses a combination of Direct and Indirect-Gain systems that use water drums and a masonry floor as heat storage in the attached greenhouse. Thermosiphoning can use direct-gain from the flow of air created by the difference in pressure between the less dense warmer air of the room and the cooler air near the ground.