Académique Documents
Professionnel Documents
Culture Documents
Design 32:
Back tube
Belt routing over retractor mtg. bracket, back tube and wire belt exit
III. Detailed Analysis Results Pictures shown after structure is stabilized at 100% loading.
Design 32 Iteration 63
Design 32 Iteration 63
Design 32 Iteration 63
LH side 18139 N
Lap belt
RH side 8647 N
Upper Shoulder Belt
Shoulder
Tension (Belt Exit 7162 N
belt
Point)
Design 32 Iteration 63
LH cushion rear
A = 33497.1 SR = 14740.6
RH cushion front
A = 27433.1 SR = 2695.63
LH cushion front
A = 34330.1 SR = 3476.26
A = axial force, SR = shear resultant
CG bars
This iteration used Test Set-Up Revision Level 0 (for analysis W.O. # 233.41800.001.G).
Attached is the Test Set-Up Specification Sheets that details this set-up condition:
16200 N
Acrobat Document
4261 N
Acceptance Criteria:
• Seat must hold FMVSS + 20% loads without any part fracture.
• Mechanisms must not fail or disengage (analysis cannot predict this, other than by
recovering loads from the analysis and comparing to the mechanism’s rated strength).
May-26-2005 17 W.O. # 233.41860.001.G
Seat: Toyota Tundra 20% Front Seat FEA Design Level #: 32
Load Case: FMVSS 207/210 Load Case Iteration #: 63
V. Analysis Methods Summary
The following standardized JCI methods were used for this analysis iteration(s):
Revision
JCI Analysis Method Comments/Exceptions
Level
207/210 General Analysis
1
Procedure (1/1/05)
(207210_Analysis_Procedure.pdf)