Académique Documents
Professionnel Documents
Culture Documents
Test
LEE CHUN YEE 0321748
Aim:
To study the workability of concrete.
Apparatus Required:
(a) Compacting Factor apparatus
(b) Trowels
Procedure:
Step 1:- Apply Grease on inner surface of the apparatus
Step 2:- Measure the mass as w1 kg by weighing the cylinder
accurately and fix the cylinder on the base in such a way that the
central points of hoppers and cylinder lie on one vertical line and
cover the cylinder with a plate.
Procedure:
Step 3:- For each 5 kg of aggregate mixes are to be prepared with
water-cement ratio by weight with 2.5 kg sand and 1.25 kg of
cement and then add required amount of water thoroughly until and
unless concrete appears to be homogeneous.
Step 4:- fill the freshly mixed concrete in upper hopper part. Two
minutes then release the trap door so that the concrete may fall into
the lower hopper such that it bring the concrete into standard
compaction.
Procedure:
Step 5:- Fall the concrete to into the cylinder causes the concrete in
standard Compaction immediately after the concrete has come to
rest and open the trap door of lower hopper and then remove the
excess concrete above the top of the cylinder.
Procedure:
Step 6:- Clean the cylinder from all sides properly. Weight the
partially compacted concrete thus filled in the cylinder and say it W2
kg. After this refill the cylinder with the same sample of concrete in
approximately 50 mm layers, by vibrating each layer heavily so as to
expel all the air and obtain full compaction of the Concrete.
Procedure:
Step 7:- Struck off level the concrete and weigh and cylinder filled
with fully compacted concrete. Let the mass be W3 kg.
CALCULATION
The compaction factor is defined as the ratio of the weight of
partially compacted concrete to the weight of fully compacted
concrete. It shall normally to be stated to the nearest second
decimal place.
Compaction Factor= (W2-W1/ W3-W1)
Precaution
1. Accurate amount of water, cement and sand are to be taken to avoid collapsing of sample.
2. Maintain the consistency throughout the experiment to avoid the failure.
3. Convenient time for releasing the concrete from the upper hopper has been found to be two
minutes after the completion of mixing
Age of concrete
In theory, provided the concrete is not allowed to dry out, then it will always be
increasing slowly at an ever reducing rate.
For convenience and for most practical applications, It is generally accepted that
the majority of the strength has been achieved by 28 days.
The table below shows the compressive strength gained by concrete after 1, 3, 7, 14 and 28
days
Age
1 day
16%
3 days
40%
7 days
65%
14 days
90%
28 days
99%
Temperature
The rate of hydration reaction is temperature dependent.
Temperature increases, the reaction also increases.
The concrete kept at higher temperature will gain strength more quickly than a similar
concrete kept at a lower temperature.
The final strength of the concrete kept at the higher temperature will be lower.