Académique Documents
Professionnel Documents
Culture Documents
DRIVE TEST
SAQIB BABAR
OBJECTIVE
The objective of the drive test is to check the physical situation of our
network.
The important parameters check during drive test are:
Rx-level, Rx-Qual, C/I (carrier to interference), BCCH,TCH.
Drive test inform us about the weakness in a coverage.
Any further step to improve the network, is based on the drive test data.
Dedicated Mode
During this mode we analyze our network by making a call.
The different aspects check during this analysis are:
Rx-Level
Rx-Qual
C/I
Over shoots
Scanned Mode
By scanning we mean, to check the Rx level of the downlink frequency channels i.e. we analyze only BCCH.
Though this type of drive test could not gives us the real picture
of our network, but we got the idea of our coverage.
Connecting Procedure:
STEPS:
1. Open TEMS.
2. Go to
3. Now, USB of
4. Go to port
Cell File
GPS
TEMS
Important:
Since all of analysis are based upon drive test data so a lot of
care needed during drive test.
An ideal drive test is the one in which every street after 100m in a
populated area is covered to collect log file data.
It is not necessary to go near the site but the coverage area of
that site should not left
The maximum sped of the car is 60km/hr.
During drive test it is necessary to analyze the data our self.
Points to Remember:
Full Level: It includes those time slots in which data is being
transferred from both the sides, means from tems &
the dialed number.
Sub Level: It includes Those time slots in which data is only
being transferred from the tems.
Carrier to interference:
C1 & C2:
This behavior displayed in idle mode & shows us the strongest cell
in which we connect & the next strongest cell.
If we have two frequencies then it shows the dominant server.