Académique Documents
Professionnel Documents
Culture Documents
A Winning Team!!
X2
(2,600)
(11,990) X 2 =
(.216) x 2 = .432 amplitude, or 7/16 amplitude
Position # 1
Position # 2
Position # 3
Position # 4
Hydraulic reservoir
Pump drive
Safety (cont.)
Do not operate or perform any lubrication, maintenance, or repair on
this equipment until you have read and understand the applicable
information in the Operation & Maintenance manual.
The information, specifications, and illustrations in the manuals are
based on information available at the time it was written. The specs,
torques, pressures, measurements, adjustments, illustrations, and
other items can and do change at any time. These changes can effect
the performance and service given to the product. Obtain the latest
and most complete information about the product to be used prior to
job start-up. MKT Manufacturing, Inc & MKT distributors have the most
current information available.
Safety (cont.)
Use caution when removing filler caps, grease fittings,
pressure taps, breathers or drain plugs. Hold a rag over
the cap or plug to prevent being sprayed or splashed by
hot liquids under pressure.
Always wear hard hat, protective glasses, hearing
protection, and other protective equipment as required.
Avoid wearing loose fitting clothing or jewelry that can get
caught on controls or other parts of equipment.
Make certain all protective guards & covers are in place
Use all cleaning solutions w/ care.
Report all needed repairs.
Safety (maintenance)
To properly service the equipment, stop the hammer or drill, & engine.
Disconnect battery whenever performing any maintenance or before
servicing the electrical system. If engine has electric starters,
disconnect and protect the battery ground leads to prevent accidental
start-up
NEVER attempt any repairs or adjustments to the engine or hammer
while it is running.
Do not attempt repairs or adjustment you do not understand. Call the
factory! Use proper tools: replace or repair broken or damaged
If applicable, block or restrain the equipment before performing
maintenance.
Do not adjust, or set, hydraulic pressures. Contact MKT to have a
factory trained technician perform this work.