filler content effects which property of composite? 1.Thermal expansion 2.Thermal Contraction 3.Biocompatibility 4.Both 1 and 2 5.Polymerization shrinkage
Silanes are considered coupling agents
because they form a bond between : 1.Resin (organic matrix) and Filler (inorganic) phases. 2.Resin (organic matrix) and initiator. 3.Initiator and activator to form a system. 4.Both 1 and 3 5.None of the above
Beneficial properties contributed by the
filler are: 1.Lowering coefficient of thermal expansion 2.Increased surface hardness and strength 3.Lowering setting contraction/polymerization shrinkage 4.All of the above 5.None of the above
material, which initiator-activator system is correct: 1.Camphorquinone - Light 2.Benzoin Methyl Ether - Light 3.Benzoyl Peroxide Light 4.N, N Dimethyl-p-Toluidine Light 5.Both 1 and 3
Regarding MICROFILLED COMPOSITE,
filler (silica) particle size range is: 1.0.1 - 1 um 2.0.01 - 0.1 um 3.0.001 - 0.01 um 4.1 - 100 um 5.None of the above
10
Thickness of the resin that can be
converted from monomer to polymer under specific light curing conditions is called? 1.Degree of conversion 2.Configuration Factor 3.Depth of cure 4.Oxygen inhibited layer 5.None of the above
11
Which of the following is true regarding
the effects of polymerization shrinkage : 1.Break in marginal seal 2.Development of stresses within composite 3.Development of stresses on tooth 4.All of the above 5.Only 1 and 2
12
Which is true about C-Factor :
1.It is the ratio of Unbounded to bounded surface 2.It is the ratio of Bounded to unbounded surface 3.More value of C-Factor shows less stresses 4.All of the above 5.Only 1 and 3
13
Relation between filler and COTE is:
1.Increasing the filler causes increase in value of COTE 2.No relation exists between filler content and COTE 3.Increasing filler content causes decrease in value of COTE 4.Decrease in filler cause decrease in COTE 5.None of the above
14
A layer of resin, collagen and dentine
produced after acid etching of dentine and application of adhesive/DBA is called: 1.Resin Tags 2.Smear layer 3.Hybrid layer 4.Oxygen inhibited layer 5.Conditioned dentine
15
Some hybrid composites contain blend of
three different particle sizes of filler. The filler content/percent in these composites can be upto: 1.70% by wt 2.85% by wt 3.75% by wt 4.95% by wt 5.90% by wt
16
For light activated composites, the typical
rise in temperature is about: 1.1-5C 2.5-15C 3.20-25C 4.10C 5.There is no rise in temperature as polymerization is an endothermic process