Académique Documents
Professionnel Documents
Culture Documents
Custom-made Services
Cost-effectiveness
INAP
Dialed Access –
This access is defined on dialing a particular B number e.g. 1802102.
When a subscriber (whether a CAMEL subscriber or otherwise) dials a particular
number for which a CAMEL trigger is defined, the IN Service Access is triggered.
This type of trigger is defined within the routing table of the SSP.
This could be used for services like Calling Card, Freephone, VPN, etc.
SCCP
MTP
•The ITU defines a Capability Set as the set of services and service features
supported in a given IN release.
B- ISDN CS-3
PSTN, ISDN CS-2
CS-1
•Mobile service •Fixed/mobile Networks
•Voice Services •Multimedia Services •IN/B-ISDN Integration
•INCM •CS-1 Extensions •IN/TMN Integration
•Basic Call Model •IN Service Creation •Special Resources
•IN Architecture •IN Management
•INAP •IN Intetworking
ii) The gsmSSF functionality, which resides in the VPLMN or interrogating network, communicates
with gsmSCF by using the CAMEL application protocol (CAP)
ii) The VLR stores CAMEL subscription information received from an HLR during the update location
procedure or at any other time as a result of changes in the roamer’s data and also provides the
roamer status if interrogated by other entities.
iii) The gsmSSF and gsmSCF communicate to each other by using the CAMEL application protocol.
iii) The interface is used to exchange routing information, subscriber status, location information,
subscription information, and suppression of announcements. In addition, CAMEL-related
subscriber data that is passed to the IPLMN is sent over this interface.
- Points in Call
- Detection points
- Transitions
- Events
Request Report BCSM (RRBE) - This operation is used to request the SSF to
monitor for a call-related event (e.g., BCSM events such as busy or no-answer),
then send a notification back to the SCF when the event is detected.
Apply Charging (AC) - This operation is used for interacting from the SCF with
the SSF charging mechanisms. The ApplyChargingReport operation provides the
feedback from the SSF to the SCF.
Continue - This operation requests that the SSF proceed with call processing
at the DP at which it previously suspended call processing to await SCF
instructions. The SSF continues call processing without substituting new data
from the SCF.
Event Report BCSM (ERB) - This operation is used to notify the SCF of a call
related event previously requested by the SCF in an RRBCSM Event operation.
The monitoring of more than one event can be requested with a
RequestReportBCSMEvent operation. Each requested event is reported in a
separate EventReportBCSM operation.
Queries:
Arshe.alam@syniverse.com