Académique Documents
Professionnel Documents
Culture Documents
#include <16f877A.h> ;
#use delay (clock = 1000000)
#fuses XT , noput
void main(void)
{
while (1)
{
output_high(PIN_B7);
delay_ms(1000);
output_low(PIN_B7);
delay_ms(1000);
}
}
is used to mechanically support and electrically connect
electronic components using conductive pathways, tracks or
signal traces etched from copper sheets laminated onto a non-
conductive substrate. It is also referred to as printed wiring
board (PWB) or etched wiring board.
6) Then put it inside the etching solution to get rid of all not needed
copper and only remains the needed copper for wiring ( from 15 – 20
mins) and at 50 degrees
7) Check under microscope if it contains short circuits (SC) or with
Multimeter and if there is any short circuits etch it again till all is gone
9) Make holes required for the design by the drilling machine size
10) Start soldering ICs in its suitable places according to your design
These steps are required to design PCB and it should be done in
reality .. But for simplicity hand out your design and you will get it
printed and ready for soldering and integrating ICs on it.
http://www.pcb-pool.com/ppuk/service_specifications.html
http://www.piclist.com/images/www/hobby_elec/e_eagle20.htm#2
http://www.hcilab.org/resources/boardlayout/eagle-librarydesign.htm
Main menus toolbar
Schematic area
Toolbox
Main menus toolbar
Layout Area
Toolbox
It is the package that allows the usage of devices with Pins
and holes on the PCB
3) Add elements to eagle library from its data sheet with real
physical dimensions