Vous êtes sur la page 1sur 31

FCOA Installation & Commissioning

Imtiaz Hussain

Installation

Module Installation

Installation of guide Plates

222 Configuration Setting

Roxtec

Roxtec Position

Installation of BUS,RF and Power cables

External cable routing from Bottom

External cable routing from TOP

Cabinet Power Up and cable routing

Nokia Flexi EDGE System Module (ESMA, 3HU)


Module for BTS common functionalities and internal/external connections Supports up to 6 DTRX modules (up to 12TRX) 5 main functions of the module:
BTS O&M: SW downloading and storing (2 * BTS SW), configuration management, reference clock and alarms BTS integrated transport: Abis transmission BB switching: communication between modules via Ethernet switch BTS power distribution: single point for power intake and power distribution to all modules BTS internal and external synchronization
Synchronization Out In PDU (power distribution unit) 48V intake PDU (power distribution unit) 6x48V to other modules 6x Ethernet to DTRX or RTC Site support system, MIBBU alarms (6), Aux equipment Q1, Local Management Port (LMP) Interchangeable Transport module: 8xE1, 8xE1/T1 or 2x Flexbus 1xEAC (External Alarm & Control) 12x alarm inputs+6x control outputs

HU = 44.4 mm

Nokia Flexi EDGE Dual Duplexer Module (ERxA, 1HU)


Dual duplexer (DDU) module together with Dual TRX create a logical Sector module
Min 1 DDU per sector is needed DDU is attached to DTRX module

DDU provides
duplex functionality to combine TX and RX signals to same antenna feeder multicoupling 2 antenna connections (for 1 or 2 sectors)
2 TX inputs and 4+4 RX outputs (4 RX from antenna 1 and 4 RX from antenna 2)

DDU contains
2 duplex filter 2 Low Noise Amplifiers (LNAs) with high/low gain support for RX signal 2 Bias-Ts with VSWR measurement functionality

TRX loop is controlled through the DDU


Common TRX loop for all TRXs in same sector Loop can be performed from either TX to any of 8 RX outputs (only 1 TX and 1 RX can be simultaneously tested)

Ant 1 TX 1

4xRX 1 4xRX 2 RX for TX 2 RX for external BTS external BTS

Ant 2

HU = 44.4

Nokia Flexi EDGE Dual TRX Module (EXxA, 2HU)


Dual TRX module (DTRX) is a 2 carrier TRX unit, used as:
a stand alone TRX module (2 TRX capacity) or a Sector module with the Dual duplexer module (2 TRX capacity) or as Double Power TRX, DPTRX (1 TRX capacity) or for Intelligent Downlink Diversity, IDD (1 TRX capacity)

DTRX consists of:


BB part that is common to both TRXs RF part with 2 independent transmit (TX) chains and 4 receive (RX) chains 0-2 Wideband combiner (WBC) sub-modules 2-way diversity: 4-way diversity: 2 RX inputs/DTRX used when both TRXs are in same sector 4 RX inputs/DTRX used when TRXs of the DTRX are in 2 different sectors 4 RX inputs/DTRX used (supported only with SRC or DPTRX)

RX connections for diversity:

DTRX connected to system module via single Gigabit Ethernet interface Power feed from system module via single cable
Phase feedback from WBC (DPTRX) 1xDTRX-DDU 1xPower TX 1 4xRX

TX 2

1xBus 0-2xWideband combiners HU = 44.4 mm

FCOA Commissioning

IP Setting for connecting with FCOA

Commissioning manually or by SCF file

Site Specific Information

Manual Hardware Configuration

Antennae Cabling

Setting VSWR Standards

Battery Bank Data Entry

Transmission Parameter Setting

E1 Selection

Clock Synchronization

Abis Connection

Abis Allocation

Abis Topology

X Connection

For Remote excess

Downloading of Configuration File

Site Commissioned after Downloading of configuration file

Thanks

Vous aimerez peut-être aussi