Académique Documents
Professionnel Documents
Culture Documents
To set the ODU parameters see the chapters on Equipment Setup and Provisioning. To view the alarm/ status display of the ODU:
MODEM Tab
To set the modem parameters see the chapters on Equipment Setup and Provisioning. To view the alarms and status of the modem:
Setting the Selected Input to Alarm or Status 1. Enter the desired name of the selected input in the Name field. A maximum of 32 characters can be used. 2. Select the desired input condition in the Condition section. You can select from the following three (3) choices such as the alarm is reported when Event ON (the selected input terminal is closed loop condition) or the alarm is reported when Event OFF (the selected input terminal is open condition) or the just Status information is reported instead of the alarm. 3. Enter the status strings corresponding to the input condition in the Event ON and Event OFF field in the Status Strings section. A maximum of 32 characters can be used. 4. The alarm input severity is defined in the ITU-T X.733 Recommendation. Select the description of the Severity, Alarm Type and Probable Cause fields in the X.733 section by clicking the pull-down arrow ( ) on the right-hand side of the selection
CPU Reset
Click the [Update] button to activate and save the new configuration file(s).
The equipment configuration file contains the wireless configuration data (i.e.frequency, main interface) and provisioning data (i.e. BER alarm threshold). *This window is not available when MAINT is OFF.
This function is used to configure the equipment network settings (i.e. IP and routing addresses, subnet masks) using the tags in the lefthand field of the Equipment Network Settings window of the selected NE for the PNMT PC.
Maintenance
TX Mute Control
CW Control
The Linearizer function is used to remove the distortion from the main amplifier in the ODU. This feature is set to Auto by default. If you need to turn it off during maintenance:
Linearizer Control
RF Setting