Vous êtes sur la page 1sur 21

A Mini Project Seminar On

BY

T.SUMAN REDDY (08681A0480) R.PRUTHVISAGAR REDDY (08681A0470) Under the esteemed Guidance of Mr. G.RAMCHANDER Asst. Professor

T.JAIPAL REDDY (08681A0484) U.SRINIVAS REDDY (08681A0485)

DEPARTMENT OF ELECTRONICS & COMMUNICATION ENGINEERING CHRISTU JYOTI INSTITUTE OF TECHNOLOGY & SCIENCE Colombo nagar , Yeshwanthapur , Jangaon , Warangal-506167 2011-2012

The project is aimed at developing the security of Home against Intruders . In the above case while you are out of your home than the device sends SMS to the emergency no provided to it. The report consists of a background into the area of 8051 microcontroller and mobile communication, how they are interfaced to each other and AT (Attention) commands set used in communication. This prototype project is basically developed to get customize the things automatically (Device Controlling).

The main theme behind this project is to develop a microcontroller based circuit which helps in increasing the security system in case of industries , homes , banks and shops from intrusion.

There is a requirement of two different voltage levels. Those are 5V DC power supply. 9V DC power supply. Design the power supply section which converts 230V AC in to 5V DC. 230V AC is too high to reduce it to 5V DC, we need a step-down transformer.
BRIDGE RECTIFIER converts AC to pulsating DC.

Microcontroller AT89S52

MAX 232

IR sensors
Liquid crystal display GSM module

Compatible with MCS-51 Product. 4.0V to 5.5V Operating Range. Fully Static Operation: 0 Hz to 33 MHz.

256K Internal RAM.


32 Programmable I/O Lines

Eight Interrupt Sources


Low-power Idle and Power-down Modes Power-off Flag

Four level translators Two RS232 transmitters

Two RS232 receivers


Operates with 5v power supply Low supply current 8mA

Electromagnetic spectrum
FEATURES: Wave length is 940 nm.

Chip material =GaAs with AlGaAs


window. Medium Emission Angle, 40. High Output Power. Ideal for remote control applications.

Monochromic pixels arranged in front of light source. Display data RAM

Built in oscillator
Contrast depends on power supply voltage

Requires SIM to activate communication.


It can send /receive messages. It requires AT commands to interact with microcontroller.

KEIL Vision IDE Overview:


Nine basic data types, including 32-bit IEEE floating-point.
Flexible variable allocation with bit, data, bdata, idata, xdata, and pdata memory types.

Interrupt functions may be written in C.


Full use of the 8051 register banks. Complete symbol and type information for source-level debugging.

Use of AJMP and ACALL instructions.


Support for the Philips 8xC750, 8xC751, and 8xC752 limited instruction sets. Support for the Infineon 80C517 arithmetic unit.

Creating a schematic design. Simulating the design. Board design using ORCAD layout. The tutorial focuses on the sequence of steps to be performed in the PCB design cycle for an electronic

design.

Mobile phone acts as a receiver.


Mobile phone gets the message sent by the transmitter. Most mobiles operate in 900MHZ or 1800MHZ frequency.

Increases the security system.


It is global.

Low cost.
Less delay in time.

It can be used in banks to strengthen the security system.


In military applications. In nuclear plants.

In industries as well as homes.

This project helps in restricting the robberies up to some extent. It provides better security system. As everything goes fine it is better to implement in home.

8051 Micro Controller and Embedded Systems by Mohammad Ali. 8051 Micro Controller Architecture by Kenneth Jayala. ATMEL 89S52 Data sheets. Hand book for Digital ICs from Analogic Devices.

Vous aimerez peut-être aussi