Académique Documents
Professionnel Documents
Culture Documents
CET
OVER VIEW
Introduction Theoretical analysis Finite element analysis Results and discussion Conclusion References
(1)
THEORETICAL ANALYSIS
Nomenclature 1. da/dN - Fatigue crack propagation rate per stress cycle 2. da d- Fatigue crack growth rate with change of applied
stress f 3. i and Beginning and finishing stress levels respectively 4. maxten Maximum tensile stress level 5. max com Maximum compression stress level -
THEORETICAL ANALYSIS..
6. 8.
THEORETICAL ANALYSIS..
Development o fatigue crack propagation model for
tension-compression loading[1]
da dN =
( da
f i
d ) d = da
i
(2)
da dN = da
max ten
da + da +
max ten
max com
da + da
max com
(3)
da
max ten
max com
da = da
da
max com
=0
da / dN =
max ten
da = g ( ) d
g ( ) = A( )
A = B( r )
(10)
]}
(11)
da / dN = B (0 ) (00 ys ) 0 ( K max ) / /
][
+0
(12)
max = (0 ) ( K max ys )
(13)
0 + +0 ( )
(14)
da / dN = C 0 ( max com / ys )
] (K )
max
0 + +0 ( )
(15)
The crack tip plastic zone size at the peak applied tensile stress[2]
CONCLUSIONS
In a tension-compression load cycle, the compression part of the
load cycle has a significant effect on the near crack tip parameters. In a tension-compression load cycle, the two loading parameters dominating the near crack tip local parameters are maximum applied stress intensity factor and maximum applied compressive stress A fatigue crack propagation equation has been successfully used to explain the experimental observed fatigue crack growth behavior.
REFERENCES
1. J. Zhang , X.D. He, S.Y. Du. Analysis of the eects of
compressive stresses on fatigue crack propagation rate. International Journal of Fatigue 29 (2007) 17511756. 2. J. Zhang , X.D. He, B. Suo, S.Y. Du. Elasticplastic nite element analysis of the effect of compressive loading on crack tip parameters and its impact on fatigue crack propagation rate. Engineering Fracture Mechanics 75 (2008) 52175228. 3. J. Zhang, X.D. He, Y. Sha, S.Y. Du. The compressive stress effect on fatigue crack growth under tensioncompression loading. International Journal of Fatigue 32 (2010) 361367.
compressive load and underload on the threshold behaviour of a 2024-T351 aluminium alloy. In:Beevers J, editor. Fatigue, vol. 84. MPCE; 1984. p. 17990.