Académique Documents
Professionnel Documents
Culture Documents
Presented by Batch 1 Akilesh Khanna(09A202) Anish Kumar.V(10A205) Jothi Raj.P(10A217) Kishore.H(10A220) Nandha Kumar.K(10A226) Thiyagaprabhu.S.S(11A448)
23-03-2012 Department of automobile engineering 1
BRAYTON CYCLE
Brayton cycle is a closed gas turbine cycle in which the compression and expansion processes remain the same. Comparing the power cycles combustion bis replaced by a constant-pressure heat-addition process from an external source The exhaust process is replaced by a constant pressure heat-rejection process to the ambient air.
23-03-2012
Process:
1-2 Isentropic compression (in a compressor) 2-3 Constant-pressure heat addition 3-4 Isentropic expansion (in a turbine) 4-1 Constant-pressure heat rejection
23-03-2012
23-03-2012
Efficiency
rp pressure ratio=
Actual vs Ideal
where states 2a and 4a are the actual exit states of the compressor and the turbine, respectively, and 2s and 4s are the corresponding states for the isentropic case
23-03-2012 Department of automobile engineering 6
Actual vs Ideal
some pressure drop during the heat-addition and heat rejection processes is inevitable. The actual work input to the compressor is more. The actual work output from the turbine is less because of irreversibilities.
23-03-2012
The deviation of actual compressor and turbine behaviour from the idealized isentropic behaviour can be accurately accounted for by utilizing the isentropic efficiencies of the turbine and compressor as,
23-03-2012
RANKINE CYCLE
Rankine cycle is the ideal cycle for vapor power plants. The ideal Rankine cycle does not involve any internal irreversibilities process: 1-2 Isentropic compression in a pump 2-3 Constant pressure heat addition in a boiler 3-4 Isentropic expansion in a turbine 4-1 Constant pressure heat rejection in a condenser
23-03-2012 Department of automobile engineering 9
RANKINE CYCLE
23-03-2012
10
Efficiency
23-03-2012
11
Actual vs Ideal
23-03-2012
12
Actual vs Ideal
The actual vapor power cycle differs from the ideal Rankine cycle as a result of irreversibilities in various components. Fluid friction and heat loss to the surroundings are the two common sources of irreversibilities. Fluid friction causes pressure drops in the boiler, the condenser. Steam leaves the boiler at a somewhat lower pressure. The pressure at the turbine inlet is somewhat lower than that at the boiler exit due to the pressure drop in the connecting pipes. So, larger work input must be given to the pump.
23-03-2012 Department of automobile engineering 13
Actual vs Ideal
A pump requires a greater work input, and a turbine produces a smaller work output. The deviation of actual pumps and turbines from the isentropic ones can be accounted for by utilizing isentropic efficiencies.
23-03-2012
14
THANK YOU
23-03-2012
15