Académique Documents
Professionnel Documents
Culture Documents
Hydrostatics report.
Designer
Created by
Comment
Filename delf Anty 3.fbm
Design length 98.300 (m) Midship location 49.150 (m)
Length over all 101.33 (m) Relative water density 1.025
Design beam 18.800 (m) Mean shell thickness 0.0000 (m)
Maximum beam 18.800 (m) Appendage coefficient 1.0000
Design draught 6.320 (m)
Trim: 0.000
(m)
Draught Lwl Bwl Vol. mould Volume Displ. Displ. LCB
(m) (m) (m) (m^3) (m^3) (tonnes) (tonnes) (m)
0.000 93.385 14.094 0.00 0.00 0.00 0.00 0.000
0.100 97.142 14.511 21.74 21.74 22.29 22.29 50.073
0.200 97.996 14.929 79.04 79.04 81.01 81.01 50.182
0.300 98.507 15.337 161.14 161.14 165.17 165.17 50.392
0.400 98.898 15.730 251.44 251.44 257.73 257.73 50.487
11/23/2014 Page 1
Hydrostatics report
Trim: 0.000
(m)
Draught Lwl Bwl Vol. mould Volume Displ. Displ. LCB
(m) (m) (m) (m^3) (m^3) (tonnes) (tonnes) (m)
4.300 100.653 18.800 5005.22 5005.22 5130.35 5130.35 49.411
4.400 100.533 18.800 5140.93 5140.93 5269.46 5269.46 49.360
NOTE 1: Draught (and all other vertical heights) is measured above base Z=0.000
NOTE 2: All calculated coefficients based on project length, draught and beam.
Nomenclature
Draught Moulded draught, measured from baseline
Lwl Length on waterline
Bwl Beam on waterline
Vol. mould Moulded volume
Volume Total displaced volume
Displ. Displacement
Displ. Displacement
LCB Longitudinal center of buoyancy, measured from the aft perpendicular at X=0.0
11/23/2014 Page 2