Académique Documents
Professionnel Documents
Culture Documents
IEC - 60079-12 - Electrical - Apparatus - Contains Information About Gas Group MESG PDF
IEC - 60079-12 - Electrical - Apparatus - Contains Information About Gas Group MESG PDF
- m 4844891
CO M M I S S I O N É L E C T R O T E C H N I Q U E I N T E R N A T I O N A L E
0080234 8 m -
iWIïiation 79-12:
RAPPORT D E LA C E I
Publication 79-12
Première édition - First edition
1978
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
I E C 7 9 P T * 2 2 78 4844891 0080235 T m
Les renseignements relatifs à ce travail de révision, à l’établisse- Information on the work of revision, the issue of revised
ment des éditions révisées et aux mises à jour peuvent être obtenus editions and amendment sheets may be obtained from I E C
auprès des Comités nationaux de la CE1 et en consultant les docu- National Committees and from the following I E C sources:
ments ci-dessous:
Terminologie Terminology
En ce qui concerne la terminologie générale, le lecteur se For general terminology, readers are referred to I E C Publi-
reportera à la Publication 50 de la CEI: Vocabulaire Electro- cation 50: fiternational Electrotechnical Vocabulary Q.E.V.),
technique International (V.E.I.), qui est établie sous forme de which is issued in the form of separate chapters each dealing
chapitres séparés traitant chacun d’un sujet défini, l’Index with a specific field, the General Index being published as a
général étant publié séparément. Des détails complets sur le separate booklet. Full details of the I.E.V. will be supplied on
V.E.I. peuvent être obtenus sur demande. request.
Les termes et définitions figurant dans la présente publication The terms and definitions contained in the present publication
ont été soit repris du V.E.I., soit spécifiquement approuvés aux have either been taken from the I.E.V. or have been specifically
fins de cette publication. approved for the purpose of this publication.
Pour les symboles graphiques, symboles littéraux et signes For graphical symbols, and letter symbols and signs approved
d’usage général approuvés par la CEI, le lecteur consultera: by the I E C for general use, readers are referred to:
- ia Publication 27 de la CEI: Symboles littéraux à utiliser - I E C Publication 27: Letter symbols to be used in electrical
en électrotechnique; technology;
- la Publication 117 de la CEI: Symboles graphiques recom- - I E C Publication 117: Recommended graphical symbols.
mandes.
Les symboles et signes contenus dans la présente publication The symbols and signs contained in the present publication
ont été soit repris des Publications 27 ou 117 de la CEI, soit have either been taken from I E C Publications 27 or 117, or
spécifiquement approuvés aux fins de cette publication. have been specifically approved for the purpose of this publi-
caiion.
Autres publications de la C E 1 établies par le même Other I E C publications prepared by the same
Comité d’Etudes Technical Committee
L’attention du lecteur est attirée sur la page 3 de la couverture, The attention of readers is drawn to the inside of the back
qui énumère les autres publications de la CE1 préparées par le cover, which lists other I E C publications issued by the Technical
Comité d‘Etudes qui a établi la presente publication. Committee which has prepared the present publication.
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
COM M ISS10 N É L E G T R O T E C H N I Q U E I N T E R N A T I O N A L E
RAPPORT DE LA C E 1
Publication 79-12
Première édition - First edition
1978
-2-
.
MAmRIEL ÉLECTRIQUE POUR ATMOSPHÈRES EXPLOSIVES
PRÉAMBULE
1) Les décisions ou accords officiels de la CE1 en ce qui concerne les questions techniques, préparés par des Comités d’Etudes
OU sont représentés tous les Comités nationaux s’intéressant à ces questions, expriment dans la plus grande mesure possible
un accord international sur les sujets examinés.
2) Ces décisions constituent des recommandations internationales et sont agréées comme telles par les Comités nationaux.
3) Dans le but d’encourager l’unification internationale, la CE1 exprime le vœu que tous les Comités nationaux adoptent
dans leurs règles nationales le texte de la recommandation de la CEI, dans la mesure où les conditions nationales le
permettent. Toute divergence entre la recommandation de la CE1 et la’ règle nationale correspondante doit, dans la
mesure du possible, être indiquée en termes clairs dans cette dernière.
PREFACE
Le présent rapport a été établi par le Comité d’Etudes No31 de la CEI: Matériel électrique pour atmosphères explosives.
I1 constitue une partie d’une série de publications traitant du matériel électrique utilisé dans les atmosphères explosives.
Les parties suivantes de la Publication 79 de la CEI: Matériel électrique pour atmosphères explosives, sont déjà parues;
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
The following countries voted explicitly in favour of publication:
Australia Japan
Austria Netherlands
Belgium Poland
Canada South Africa (Republic of)
Denmark Spain
E!ZYPt Sweden
France Switzerland
Germany Turkey
HwwY Yugoslavia
The United States National Committee voted against publication of this report because it considered that, for some gases
classified in this manner, changes in the maximum experimental safe gap (MESG) and variafions in the degree of pressure
enhancement which may occur under pressure piling and turbulent conditions could result in a factor of safety of less than
unity under actual conditions.
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
MATÉRIEL ÉLECTRIQUE POUR ATMOSPHÈRES EXPLOSIVES
1. Domaine d’application
Le présent rapport donne des directives pour le choix du groupe ou sous-groupe approprié de
matériels électriques protégés par une enveloppe antidéflagrante ou conçus de façon à être à
sécurité intrinsèque, d’après le gaz ou la vapeur,dans lesquels les matériels sont destinés à être
utilisés.
Le présent rapport indique les critères de classement des gaz et des vapeurs les plus courants.
Des conseils sont donnés au sujet des essais à exécuter pour classer les gaz ou vapeurs non
mentionnés dans le présent rapport.
soirement.
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
ELECTRICAL APPARATUS FOR EXPLOSIVE GAS ATMOSPHERES
Part 1 2 Classification of mixtures of gases or vapours with air
according to their maximum experimental safe gaps
and minimum igniting currents
r
1. Scope
This report provides guidance on the selection of the appropriate group or sub-group of electrical
apparatus, protected by flameproof enclosure or designed to be intrinsically safe, according to the
gas or vapour in which it is intended to be used.
This report provides the basis for the classification of the most used gases and vapours. Guidance
is given on the tests to be carried out to classify any additional gases or vapours not listed in
this report.
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
classer le gaz ou la vapeur.
Une seule détermination est suEsante lorsque:
Groupe IIA: 1’IEMS est supérieur à 0,9 mm, ou le rapport CMI est supérieur à 0,9.
Groupe IIB: 1’IEMS est compris entre 0,55 mm et 0,9 mm, ou le rapport CMI est compris entre
0,5 et 0,8.
Groupe IIC: I’IEMS est inférieur 0’5 mm, ou le rapport CMI est inférieur à 0’45.
I1 est nécessaire de déterminer à la fois I’IEMS et le rapport CMI dans les cas suivants:
1) Seul le rapport CMI a été déterminé et sa valeur est comprise entre 0’8 et 0’9, la détermination
de I’IEMS est alors nécessaire pour classer le gaz ou la vapeur.
2) Seul le rapport CMI a été déterminé et sa valeur est comprise entre 0,45 et 0,5, la détermination
de I’IEMS est alors nécessaire pour classer le gaz ou la vapeur.
3) Seul 1’IEMS a été déterminé et sa valeur est comprise entre 0,5 mm et 0,55 mm, la détermi-
nation du rapport CMI est alors nécessaire pour classer le gaz ou la vapeur.
Le classement présenté dans ce rapport donne des indications sur les groupes de matériels élec-
triques à utiliser dans un mélange particulier de gaz/air afin d’éviter les risques d’explosion
d’origine électrique. Il convient de remarquer que certaines des substances énumérées, comme le
nitrate d’éthyle, sont relativement instables et peuvent se prêter à une décomposition spontanée.
La liste des gaz et vapeurs de ces tableaux ne vise pas à être exhaustive.
Toutes les formes isomériques des produits classés sont comprises.
La signification des lettres affectées à chaque gaz est la suivante:
a = classement d’après la valeur de I’IEMS.
b = classement d’après la valeur du rapport CMI.
c = 1’IEMS et le rapport CMI ont été déterminés. ,
d = classement en fonction de la similitude de structure chimique (classement provisoire).
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
The groups of apparatus are:
Group I: mining applications (methane).
Group II: applications in other industries.
Group II apparatus is subdivided and, for the purpose of classiûcation of gases and vapours,
the MIC ratios are:
Group IIA: MIC ratio above 0.8.
Group IIB: MIC ratio between 0.45 and 0.8.
Group I I C MIC ratio below 0.45.
Group IIC: the MESG is less than 0.5 mm, or the MIC ratio less than 0.45.
Determination of both the MESG and MIC ratio is required when:
i) The MIC ratio determination only has been made, and the ratio is between 0.8.and 0.9, when
an MESG determination will be required to classify the gas or vapour.
2) The MIC ratio determination only has been made, and the ratio is between 0.45 and 0.5, when
an MESG determination will be required to dassify the gas or vapour.
3) The MESG only has been found, and is between 0.5 mm and 0.55 111111, when an MIC ratio
determination will be required to classify the gas or vapour.
3. Tables of gases
The classification in this report provides guidance on the group of electrical apparatus to be
used in a particular gaslair mixture to avoid the danger of an explosion from an electrical source.
It should be noted that some materials listed, for example ethyl nitrate, are relatively unstable
and may be prone to spontaneous decomposition.
The list of gases and vapours in the tables should not be considered to be comprehensive.
All isomeric forms of the compounds listed are included.
The significance of the letter against each gas is as follows:
a = classiñed according to MESG determination.
b = classified according to MIC ratio.
c = both MESG and MIC ratio have been determined.
d = classiñed according to similarity of chemical structure (provisional classification).
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
=
~
I
TABLEAU TABLEI
Gaz ou vapeurs pour lesquels un matériel Gases or vapoursfor which Group IIA
électrique du groupe IIA est requis apparatus is required
1. Hydrocarbures
Hydrocarbons
1.1 Alcanes
Alkanes
Méthane
Methane CH4
Ethane
Ethane C2H6
Propane CsH8
Butane C4H10
Pentane C5H12 C
Hexane CBH14 C
Heptane c7H16 C
Octane GH18 a
Nonane d
Décane
Decane ClOH22 a
Cyclobutane d
Cyclopentane a
Cyclohexane C
Cycloheptane d
. Méthylcyclobutane
Methylcyclobutane d
Méthylcyclopentane
Methylcyclopentane d
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
MBthylcyclohexane
. Methylcyclohexane d
Ethylcyclobutane
Ethylcyclobutane d
Ethylcyclopentane
Ethylcyclopentane d
Ethylcyclohexane
Ethylcyclohexane d
Décahydronaphtalène (décaline)
Decahydronaphthalene(dekalin) d
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
- 11 -
1.2 Alcènes
Aikenes
Propène (propylène) a
Propene (propylene)
1.3 Hydrocarbures aromatiques
Aromatic hydrocarbons
Styrène
CBH5CH CH2 b .
Styrene
Isopropenylbenzene
(méthylstyrène) a
(methylstyrene)
1.4 Hydrocarbures benzéniques
Benzenoids
Benzène
Benzene
Toluène
Toluene
Xylène
Xylene
Ethylbenzène
Ethylbenzene
Triméthylbenzène
. Trimethylbenzene
Naphtalène d
Naphthalene
Cumène d
Cumene
Cymène . d
Cymene
1.5 Hydrocarbures mélangés
Mixed hydrocarbons
Méthane (industriel) l) (calculé)
Methane (industrial) i) a (calculated
Térébenthine
Turpentine
Naphte de pétrole
Petroleum naphtha
Naphte de houille
Coal tar naphtha
Pétrole
(y compris essence de pétrole)
Petroleum d
(including motor spirit)
Solvant ou essence de nettoyagi d
. Solvent or cleaning petroleum
Mazout d
Heating oil
Le méthane (industriel) comprend des mélanges contenant jusqu'à 15%, en volume, d'hydrogène.
Methane (industrial) includes methane mixtures containing up to 15%, by volume, of hydrogen.
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
Gaz ou vapeur Formule chimique Méthode de classement
Gas or vapour . Chemical formula Method of classificatior
Kérosène d
Kerosene
- Gas-oil d
Diesel oil
Benzol pour moteurs a
Motor benzole
Dipropyléther
Dipropylether (c3H7>20 a
Méthanol
Methanol CHaOH C
Ethanol
Ethanol C2HbOH C
Propanol C3H70H C
Butanol C4HgOH
Pentanol CbHnOH
Hexanol C6H130H
Heptanol C7H160H
Octano1 C6H170H
Nonanol C9Hl9OH
Cyclohexanol CH2(CH2)4CH OH d
I
Méthylcyclohexanol
Methylcyclohexanol CHsCH(CH2)4CH OH
Phénol
Phenol CeHsOH
Crésol
Cresol CH3CeH4OH
4-hydroxy-4-methylpentan-2-oni
(diacétone-alcool) d
(CH&C(OH)CHZCO CH3
(diacetone alcohol)
2.3 Aldéhydes
Aldehydes
Aldéhyde acétique
Acetaldehyde
.CHsCHO a
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
Gaz ou vapeur Formule chimique Méthode de classement
Gas or vapour Chemical formula Method of classification
Métaldéhyde d
Metaldehyde
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
2.4 Cétones
Ketones
Acétone C
Acetone
Butanone
(éthyl-méthyl-cétone) G H 5 C 0 CH3 C
(ethyl methyl ketone)
Pentan-2-one
(propyl-méthyl-cétone) C,H,CO CH3 a
(propyl methyl ketone)
Hexan-2-one
(butyl-méthyl-cétone) C4HgCO CH3 a
(butyl methyl ketone)
Amyl-méthyl-cétone C5Hi1CO CH3 d
Amyl methyl ketone
Pentane-2,4-dione
(acétylacétone) CH3CO CH&O CH3 a
(acetylacetone)
Cyclohexanone CHa(CHa)4CO a
2.5 Esters
Formiate de méthyle
H COO CH3 a
Methyl formate
Formiate d'éthyle
H COO C2H5 a
Ethyl formate
Acétate de méthyle
CH3COO CH3 C
Methyl acetate
Acétate d'éthyle
CH3COO C2H5 a
Ethyl acetate
Acétate de propyle
CH3COO C3H7 a
Propyl acetate
Acétate de butyle
CH3COO C4Hg C
Butyl acetate
Acétate d'amyle
CH3COOCSHll d
Amyl acetate
Méthacrylate de méthyle
Methyl methacrylate CH, = C(CH3)COOCH3 a
Methacrylate d'éthyle
Ethyl methacrylate CH2 = C(CH3)COOqH, d
Acétate de vinyle
Vinyl acetate CH3COOCH = CH2 a
Acétylacétate d'éthyle
Ethyl acetoacetate CH3COCH2COOC2H5 a
2.6 Acides
Acids
Acide acétique
Acetic acid CH3COOH b
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
IEC 7 4 P T * 1 2 7 8 M 4844871 0080147 T M
- 14 -
Chlorure d'allyle
CH2 = CHCHZCI b
Allyl chloride
Dichloréthylène
CHCI= CHCl a
Dichloroethylene
Chlorure de vinyle CH2 = CHCI C
Chloroethylene
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
d,d,d-trifluorotoluene
(phenyltrifluorométhane) a
C6H5CF3
(bernotrifluoride)
Dichloromethane
(chlorure de méthylène) CH2C12 d
(methylene chloride)
3.2 Composés contenant de l'oxygène
Compounds with oxygen
Chlorure d'acétyle
Acetyl chloride CHsCOCl d
Chloréthanol
Chloroethanol d
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
Gaz ou vapeur Formule chimique Méthode de classement
Gas or vapour Chemical formula tíethod of classification
Ammoniac
3
" a
Ammonia
Acétonitrile
CH&N a
Acetonitrile
Nitrite d'éthyle
CH3CHzONO a
. Ethyl nitrite
Nitrométhane d
Nitromethane
Nitroéthane d
Nitroethane
5.1 Amines
Méthylamine a
CH3NH2
Methylamine
Diméthylamine
a
Dimethylamine
Triméthylamhe
Trimethylamine a
Diéthylamine
Diethylamine d
Triéthylamhe
Triethylamine d
Propylamine d
Butylamine C
Cyclohexylamine d
2-aminoethanol
(ethanolamine) d
(mono-ethanolamine)
2-diéthylaminoéthanol
d
2-diethylaminoethanol
Diaminoéthane
a
Diaminoethane
Aniline d
NN-dimethylaniiine d
Amphétamine
Amphetamine d
Toluidine d
Pyridine d
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
II
TABLEAU TABLEII
Gaz ou vapeurs your lesquels un matériel Gases or vapours for which Group IIB
électrique du gsoupe IIB est requis apparatus is required
Hydrocarbures
Hydrocarbons
Allylène
CH& = CH
Propyne
Ethylene
Ethylene C2H4
Cyclopropane CH2CH2CH2
U ’
1,3-butadiène
1,3-butadiene CH2 = CHCH = CH2
Nitrate d’isopropyle
Isopropyl nitrate (CH3)2CHON02 b
Acide cyanhydrique
Hydrogen cyanide HCN a
Ether méthylique
Dimethyl ether
Ether méthylique d’éthyle
Ethyl methyl ether
Ether éthylique
Diethyl ether
Ether butylique
Dibutyl ether
Oxione
(oxyde déthylène)
CH2 CH2 O C
(ethylene oxide) ~.
1,2-époxypropane
1,2-epoxypropane CH3CHCH20 C
CH2CH20CH2CH20 a
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
- 17 -
~ ~ _ _ _ _
Alcool fétrahydrofurfurylique
Tetrahydrofurfuryl alcohol d
Acrylate de méthyle
Methyl acrylate CHz = CHCOOCH3 a
Acrylate d'éthyle
Ethyl acrylate CH2 = CHCOOCzH5 a
Acrylaldehyde
(acroléine) CHz = CHCHO a (calculé)
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
(acrolein) (calculated)
Tétrahydrofuranne
Tetrahydrofuran a
Mélanges
MiutUres
Tétrafluoréthylène
cZF4 a
Tetrafluoroethylene
l-chloro-2,3-epoxypropane
(épichlorohydrine) OCHzCHCH2Cl
(epichlorohydrin) .
Hydrogène
Hydrogen
Acétylène
Acetylene
Bisulfure de carbone
Carbon disulphide
Nitrate d'éthyle
Ethyl nitrate
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.
Autres publications de la CE1 préparées Other IEC publications prepared
par le Comité d’Etudes NO 31 by Technical Committee No. 31
79 : - Matériel électrique pour atmosphères explosives. 79: - Electrical apparatus for explosive gas atmospheres.
79-0 (1971) Partie zéro: Introduction générale. 79-0 (1971) Part O: General introduction.
79-1 (1971) Première partie: Construction, vérification et 79-1 (1971) Part I: Construction and test of flameproof
essais des enveloppes antidéflagrantes de matériel enclosures of electrical apparatus.
électrique.
79-1A (1975) Premier complément: Annexe D; Méthode d’essai 79-IA (1975) First supplement: Appendix D: Method of test
pour la détermination de i’interstice expéri- for ascertainment of maximum experimental
mental maximal de sécurité. safe gap.
79-2 (1975) Deuxième partie: Enveloppes à surpression 79-2 (1975) Part 2: Pressurized enclosures.
interne.
79-3 (1972) Troisième partie: Eclateur pour circuits de 79-3 (1972) Part 3: Spark test apparatus for intrinsically-safe
sécurité intrinsèque. circuits.
79-4 (1975) Quatrième partie: Méthode d’essai pour la 79-4 (1975) Part 4 Method of test for ignition temperature.
détermination de la température d’inflammation.
79-4A (1970) Premier complément l. 79-4A (1970) First supp1ement.l
79-5 (1967) Cinquième partie: Protection par remplissage 79-5 (1967) Part 5: Sand-filled apparatus.
pulvérulent.
79-5A (1969) Premier complément. 79-5A (1969) First supplement.
79-6 (1968) Sixième parfie : Matériel immergé dans l’huile. 79-6 (1968) Part 6: Oil-immersed apparatus.
79-7 (1969) Septième partie: Construction, vérification et 79-7 (1969) Part 7: Construction and test of electrical appar-
essais du matériel électrique en protection <(e». atus, type of protection “e”.
79-8 (1969) Huitième partie: Classification des températures 79-8 (1969) Part 8: Classification of maximum surface tem-
maximales de surface. peratures.
79-9 (1970) Neuvième partie: Marquage. 79-9 (1970) Part 9: Marking.
79-10 (1972) Dixième partie: Classification des zones dan- 79-10 (1972) Part 10: Classification of hazardous areas.
gereuses.
79-11 (1976) Onzième partie: Construction et essais du maté- 79-11 (1976) Part 11: Construction and test of intrinsically-
riel à sécurité intrinsèque et du matériel associé. safe and associated apparatus.
1 cc complément s’applique &gaiementà la deuxième Cdition de 1975. 1 This supplement applies also to the second edition of 1975.
--`,````,,,```,,,,`,,,``,,,,,-`-`,,`,,`,`,,`---
Publication 19-12
Copyright International Electrotechnical Commission Document provided by IHS Licensee=Fluor Corp no FPPPV per administrator /use
Provided by IHS under license with IEC new u/2110503106, 03/05/2004 00:18:51 MST Questions or comments about this
message: please call the Document Policy Group at 303-397-2295.