Académique Documents
Professionnel Documents
Culture Documents
Dimensions: suivant norme AM Tolrances: EN 10279: 2000 Etat de surface: conforme EN 10163-3: 2004, classe C, sous-classe 1
ss
b
45o
Dimensions: in accordance with AM standard Tolerances: EN 10279: 2000 Surface condition: according to EN 10163-3: 2004, class C, subclass 1
r1 y h tw tf
z
r2 d y
ys ym
Dimensions Abmessungen
tf mm r1 mm r2 mm d mm A mm2 x102 AL
Surface Oberflche
AG m2/t
m2/m
U 40 x 20 x 4* U 40 x 20 x 5* U 50 x 25 x 5* U 60 x 30 x 6* U 65 x 42 x 5.5*
40 40 50 60 65
20 20 25 30 42
* * *
Tonnage minimum et conditions de livraison ncessitent un accord pralable. Minimum tonnage and delivery conditions upon agreement. Mindestbestellmenge und Lieferbedingungen nach Vereinbarung.
U
Notations pages 205-209 / Bezeichnungen Seiten 205-209
EN 10025-2: 2004
Pure compression
G kg/m
Iy mm
4
Wel.y mm
3
Wpl.y mm
3
Avz mm
2
Iz mm
4
Wel.z mm
3
Wpl.z mm
3
ss mm
It mm
4
Iw mm
6
ys mm x10
ym S235 S355 S235 mm x10 1,15 1,01 1,34 1,50 2,60 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 S355
x104 U 40 x 20 x 4 U 40 x 20 x 5 U 50 x 25 x 5 U 60 x 30 x 6 U 65 x 42 x 5.5 2,65 2,87 3,86 5,07 7,09 7,43 7,58 16,8 31,6 57,5
x109
0,31 0,002 0,68 0,39 0,003 0,67 0,59 0,009 0,81 0,89 0,024 0,91 1,61 0,082 1,42
Wpl,y est calcul selon lhypothse dun diagramme de contraintes bi-rectangulaire et nest applicable que si deux ou plusieurs fers U sont associs de facon
constituer une section doublement symtrique pour laquelle un moment de flexion agissant dans le plan du centre de gravit nengendre pas de torsion. a way to form a double symmetric cross-section so that the bending moment acting in the plane of the centre of gravity will not lead to torsion.
Wpl,y is determined assuming a bi-rectangular stress block distribution. Thus, the given value applies only if two or more channels are combined in such Fr die Berechnung von Wpl,y wurde eine doppelrechteckige Spannungsverteilung angenommen. Der angegebene Wert ist daher nur anwendbar,
wenn zwei oder mehr U-Profile so miteinander kombiniert sind, dass sie einen doppelsymmetrischen Querschnitt bilden, womit ein Biegemoment, das in der Schwerpunktebene angreift, keine Torsion hervorruft.
EN 10225:2001
EN 10025-4: 2004
49