Académique Documents
Professionnel Documents
Culture Documents
Vehicle functions supported in this diagram (functional if equipped) | Fonctions du véhicule supportées
dans ce diagramme (fonctionnelles si équipé)
Push-to-Start Control
PUSH
T-Harness available
(vendu séparément)
Immobilizer bypass
Hand-Brake Status
START
Foot-Brake Status
(sold separately)
Hood Status*
Parking Light
RAP Disable
Trunk Status
Door Status
Tachometer
Disarm
Unlock
VEHICLE YEARS
Lock
Arm
VEHICULES ANNÉES
NISSAN
Push-to-Start
Altima (AT)
2007-2008 • • • • • • • • • • • • • • •
Push-to-Start
(AT)
2009-2012 • • • • • • • • • • • • • • • •
Coupe
Push-to-Start 2013 • • • • • • • • • • • • • • • •
(AT)
Hybrid
Push-to-Start 2007-2008 • • • • • • • • • • • • • • • •
(AT)
Hybrid
Push-to-Start 2009-2011 • • • • • • • • • • • • • • • •
(AT)
HARDWARE VERSION FIRMWARE VERSION To add the firmware version and the options, use the
VERSION MATÉRIELLE VERSION LOGICIELLE FLASH LINK UPDATER or FLASH LINK MOBILE tool,
sold separately.
MINIMUM
6 72.[40] Pour ajouter la version logicielle et les options,
utilisez l’outil FLASH LINK UPDATER
NISSAN/INFINITI MINIMUM ou FLASH LINK MOBILE, vendu séparément.
3X
REMOTE STARTER DIAGNOSTICS
DIAGNOSTIQUE DU DÉMARREUR À DISTANCE
START MODULE RED LED | DEL ROUGE DU MODULE
x2 flash : Brake ON Frein Activé
x3 flash : No tach Pas de Tach
All doors must be closed. Press the OEM remote’s Lock button 3x to The vehicle will START. x4 flash : Ignition Clé de contact
Toutes les portes doivent
remote-start (or remote-stop) the vehicle. before start détectée avant
être fermées
Appuyez sur le bouton Verrouillage 3X de la Le véhicule DÉMARRE. démarrage
télécommande d'origine pour démarrer à distance (ou x5 flash : Hood Open Capot Ouvert
arrêter à distance) le véhicule.
WARNING | ATTENTION
REMOTE STARTER
DÉMARREUR À DISTANCE
CUT THIS WARNING CARD AND STICK IT ON A VISIBLE PLACE:
or use the package RSPB, Sold separately. THE VEHICLE CAN BE STARTED BY LE VÉHICULE PEUT DÉMARRER SOIT: EN
EITHER: PRESSING THE LOCK BUTTON APPUYANT 3 FOIS CONSÉCUTIVEMENT SUR
COUPEZ CETTE CARTE D'AVERTISSEMENT ET COLLEZ-LA À UN ENDROIT VISIBLE: ON THE OEM REMOTE 3 TIMES LE BOUTON VERROUILLAGE DE LA
ou utilisez la trousse RSPB, vendue séparément. CONSECUTIVELY OR BY A TÉLÉCOMMANDE DU VÉHICULE OU PAR UN
SMARTPHONE. TURN ON THE SAFETY TÉLÉPHONE INTELLIGENT. ACTIONNEZ EN
SWITCH LOCATED UNDER THE POSITION ‘ON’ LE COMMUTATEUR DE
DASHBOARD BEFORE WORKING ON SÉCURITÉ SITUÉ SOUS LE TABLEAU DE BORD
THE VEHICLE. AVANT LES TRAVAUX D'ENTRETIEN.
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 3 / 9
DESCRIPTION | DESCRIPTION
(-)PTS
Behind cluster
Derrière l'audometre
(-)DOOR
PIN
(-)PARKING
LIGHTS
ALTIMA
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 4 / 9
OBDII
Front view
Vue de face
Hood pin
Orange/Black
Dk.Blue
In
In
A7
A7
A8
A C C2 Orange/Brown
5 PIN CONN.
A8 C1 Orange/Green
Red/Blue In A9
A9
Lt.Blue/Black A10
A10 D6 White/Red
D6
Black
Pink
Out A11
A11 D D5
D5 White/Blue 6 PIN CONN.
RL1 T-HARNESS
Out A12
A12 D4
D4 White/Green HARNAIS EN T
Start/Stop external Yellow/Black In A13
A13 D3 Yellow/Red
D3 RED CONN.
Brown/White Out A14
A14 D2 Yellow/Blue
D2
(-)Driver door Pin Pink/Black Out A15
A15 D1 Yellow/Green
D1
Purple/Yellow A16
A16
Green/White A17
A17 6 PIN CONN. RL2
Green/Red A18
A18 T-HARNESS
(-)Push-to-Start White/Black A19
A19
RL2 - Do not use HARNAIS EN T
Lt.Blue A20
A20
RL2 - Ne pas utiliser 20 PIN
WHITE CONN.
A20 Lt. Blue
Brown/White
A14
Lt. Blue/Black
A10/A16 Yellow
A1
Brown
A5 A4 A15 A19
(-)DRIVER (+)PARKING
(-)LOCK (-)UNLOCK (-)PTS
ALTIMA
For Autolight
shut down.
Pour la
fermeture des
lumières 4 3 2 1 1 2 3
automatiques.
39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 10 9 8 7 6 5 4 5 6 7 8
59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40
CAUTION :
Back View Back View
Back View - BCM Green 40-pin An incorrect connection may cause
White 10-pin Brown 8-pin Connector permanent damage to the module.
Connector behind cluster Vue
Connector At Push-to-Start Testing the voltage with a
de dos button - Vue de dos
At Driver multimeter:
BCM Connecteur Vert de 40 pins kick panel Connecteur Brun Button pressed : 0 VDC
derrière l'audomêtre Vue de dos de 8 pins Au dos du Button release : 12 VDC
1
Press and hold the Appuyez et maintenir
YELLOW
ON JAUNE If the LED is not solid YELLOW Si le DEL n'est pas JAUNE
disconnect the 4-Pin connector débranchez le connecteur 4
(Main-Harness) and go back to pins (Connecteur principal et
step 1. allez au début de l'étape 1.
3
Insert the required remaining Insérez les connecteurs
connectors. requis restants.
x2 PRESS X2 FLASH
Press and release the
programming button two
(2x) times.
Appuyez et relâchez 2 fois le
bouton de programmation.
...
PRESS
ON
The YELLOW LED will La DEL JAUNE clignote2
flash 2 times each second. fois chaque seconde.
x1
IGNITION OFF ACCESSORY ON
Press and release the Push-to-Start Appuyez et relâchez 1 fois sur le
ACC button once (x1). bouton démarrage.
ON ON
ON The RED LED will turns ON La DEL ROUGE s'allume.
ON
ON Wait for the BLUE LED to Attendre que la DEL BLEU
ON turn ON. s ’allume solide.
If the BLUE, YELLOW and RED LED’s Si les DELs ne sont pas DELs BLEU,
are not solid, press and release the JAUNE et ROUGE solide, appuyez et
PTS button twice to turn OFF the relâchez 2 fois sur le bouton poussoir
engine and then press and release pour éteindre le moteur et appuyer 1
x1
ON
x1
OFF
x1
ACC
the PTS button once again to turn
the Accessory ON.
fois pour Accessoire,
KEY BYPASS PROGRAMMING PROCEDURE 2/2 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 2/2
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 8 / 9
All doors must Press the OEM remote’s The vehicle will Unlock (required) the doors : Enter the vehicle The vehicle can
be closed. Lock button 3x to START. with the Intelligent now be put in to
remote-start (or remote- For Vehicle 2007-2008: Access Key. gear and driven.
stop) the vehicle. the remote starter remote only.
Toutes les Le véhicule
portes doivent DÉMARRE. For Vehicle 2009 and more unlock the Entrez dans le Vous êtes
être fermées. Appuyez sur le bouton
Verrouillage 3X de la doors with either: véhicule avec la clé maintenant prêt à
télécommande d'origine • The OEM remote intelligente (Access embrayer et
pour démarrer à distance • The remote-starter remote Key) sur vous prendre la route.
(ou arrêter à distance) le • Or the proximity remote
véhicule.
Déverrouillez (requis) les portes:
ALL
HARDWARE VERSION
Notice: Updated Firmware and Installation Guides
FIRMWARE VERSION
Date: xx-xx Updated firmware and installation guides are posted on our web site on a regular
EVO-ALL basis. We recommend that you update this module to the latest firmware and
INTERFACE MODULE
PATENTS PENDING US: 2007-228827-A1
download the latest installation guide(s) prior to the installation of this product.
Made in Canada www.fortinbypass.com
WARNING
The information on this sheet is provided on an (as is) basis with no representation or warranty of accuracy whatsoever.
It is the sole responsibility of the installer to check and verify any circuit before connecting to it. Only a computer safe
logic probe or digital multimeter should be used. FORTIN ELECTRONIC SYSTEMS assumes absolutely no liability or
responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in every case
is the sole responsibility of the installer performing the work and FORTIN ELECTRONIC SYSTEMS assumes no liability
or responsibility whatsoever resulting from any type of installation, whether performed properly, improperly or any other
way. Neither the manufacturer or distributor of this module is responsible of damages of any kind indirectly or directly
caused by this module, except for the replacement of this module in case of manufacturing defects. This module must be
installed by qualified technician. The information supplied is a guide only. This instruction guide may change without
notice. Visit www.fortinbypass.com to get the latest version.
MISE EN GARDE
L’information de ce guide est fournie sur la base de représentation (telle quelle) sans aucune garantie de précision et
d’exactitude. Il est de la seule responsabilité de l’installateur de vérifier tous les fils et circuits avant d’effectuer les connexions.
Seuls une sonde logique ou un multimètre digital doivent être utilisés. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume
aucune responsabilité de l’exactitude de l’information fournie. L’installation (dans chaque cas) est la responsabilité de
l’installateur effectuant le travail. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume aucune responsabilité suite à
l’installation, que celle-ci soit bonne, mauvaise ou de n’importe autre type. Ni le manufacturier, ni le distributeur ne se
considèrent responsables des dommages causés ou ayant pu être causés, indirectement ou directement, par ce module,
excepté le remplacement de ce module en cas de défectuosité de fabrication. Ce module doit être installé par un technicien
qualifié. L’information fournie dans ce guide est une suggestion. Ce guide d’instruction peut faire l’objet de changement
sans préavis. Consultez le www.fortinbypass.com pour voir la plus récente version.
Copyright © 2006-2018, FORTIN AUTO RADIO INC ALL RIGHTS RESERVED PATENT PENDING
TECH SUPPORT
Tél: 514-255-HELP (4357)
1-877-336-7797
www.fortinbypass.com
ADDENDUM GUIDE
WEB UPDATE | MISE À JOUR INTERNET