Académique Documents
Professionnel Documents
Culture Documents
Vehicle functions supported in this diagram (functional if equipped) | Fonctions du véhicule supportées dans ce
diagramme (fonctionnelles si équipé)
AUX.1
Hand-Brake Status
Foot-Brake Status
Parking Lights
Hood Status*
Heated seats
Trunk Status
Trunk (open)
Rear defrost
Door Status
Tachometer
Disarm
Unlock
VEHICLE YEARS
Lock
Arm
VEHICULES ANNÉES
VOLKSWAGEN
Tiguan Push-to-Start 2018 • • • • • • • • • • • • • • • •
MADE IN CANADA
MODULE CODE QR SUR utilisez l’outil FLASH LINK UPDATER
COMPATIBLE L’ÉTIQUETTE
© 2018 ALL RIGHTS RESERVED
TB-VW
1x TB-VW (key bypass) 1x TB-VW (contournement de clé)
DESCRIPTION | DESCRIPTION
NOTES
Vehicle’s equipped with Virtual Cluster, not Véhicule équipé d’un audomêtre virtuel, non pris en charge pour
supported for the key bypass. le contournement de clé.
( ) PARKING
LIGHTS
(~)
2
TRANSPONDER
WIRE
(-) PARKING
LIGHTS
(~) CAN (~) CAN
HIGH
HIGH1 LOW
LOW1
WITHOUT HEATED STEERING WHEEL
3 VESCM module SANS VOLANT CHAUFFANT
Module VESCM
Pull the clips to release the cover (~) CAN (+)IGNITION (-)START/ (-)START/
of the connector. Soulever les clips
pour sortir le couvert du connecteur.
HIGH2 STOP1 STOP2
Connector
Connecteur
Clips
Ground
Masse
A15
D6
1A Diode
1A Diode
5 AMP
Cut fuse
CUT
D5 D4 C2 C1 RS2/D2 C3 C4 D2
PARKING (~)CAN2 (~)CAN2 (~) CAN1 (~) CAN1 TRANS- (+) BRAKE
(+) PARKING LIGHTS (-)START/ (-)START/ PONDER
LIGHTS LOW HIGH (+)12V STOP1 STOP2 HIGH LOW CONTROL
12V WIRE
TIGUAN
Grey/Yellow Red/ Orange/ Orange/ Red/ Purple Purple/ Orange/ Orange/ Pin2 Black/Red
Gris/Jaune Purple Brown Black Blue Mauve Blue Green Brown Noir/Rouge
Rouge/ Orange/ Orange/ Rouge/ Mauve/ Orange/ Orange/
Mauve Brun Noir Bleu Bleu Vert Brun
OR OR
OU OU
12 11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 A B
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13
6 7 8 9 10
1 2 3 4 5 6 7 8
4 3 2 1
1 16 15 14 13 12 11 10 9
1 14 13 12 11 10 9 8 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38
8 7 6 5 4 3 2 1 7 6 5 4 3 2
9 10 11 12 13 14 15 16
1
16
73 66
1 2 72 71 70 69 68 67 65 64 63
WITHOUT HEATED STEERING WHEEL WITH HEATED STEERING WHEEL
6 SANS VOLANT CHAUFFANT
1
AVEC VOLANT CHAUFFANT
2 3
4 5
Back view - Red 10-pin
Connector at light OBDII Back view Back view Back view Black 2-Pin Black cover Under
switch Front view Black 4-pin Black 16-pin connector the dash Driver
transponder connector
Vue de dos Connec- Vue de face Connector
at start/stop
Connector
Under the steering Vue de dos Connecteur
side, white 3
teur Noir de 10 pins au 73-PINS
feux de stationne- button, in column Noir de 2 pins connector -
ment center console. 6 Vue de dos connecteur du
transpondeur
Back view VESCM - Electrical
Vue de dos 1 Connecteur Noir
Connecteur Noir 3 2 de 16 pins Sous la
Couvert Noir, Sous System Control
le tableau de bord
de 4 pins au colonne de direction Module
bouton
4 côté chauffeur VESCM - Module
Connecteur Blanc
poussoir dans 5 de 73 pins-
de contrôle de
système
la console Vue de dos
centrale. électrique
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 4 / 9
1
2
WARNING: ATTENTION:
Close and open the Fermez et ouvrez la
driver door. porte conducteur.
KEY BYPASS PROGRAMMING PROCEDURE 2/4 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 2/4
1
6
7
If the LED is not solid BLUE
Release the programming disconnect the 4-Pin connector
RELEASE button when the LED is (Data-Link) and go back to step 1.
BLUE.
BLUE
ON BLEU
Si le DEL n'est pas BLEU
Relâchez le bouton de débranchez le connecteur 4 pins
(Data-Link) et allez au début de
programmation quand la DEL l'étape 1.
est BLEU.
x1
PRESS
IGNITION OFF IGNITION ON
Press the Push-to-Start Appuyez 1 fois sur le bouton
IGN ON ON ON button to turn ON the démarrage (Push-to-Start) pour
ignition. allumer l'ignition.
10
Press and release the Appuyez et relâchez 1 fois
x1
IGNITION ON PRESS X1 le bouton de programmation.
programming button once
(1x).
PRESS ON OFF
The BLUE LED will La DEL BLEUE
turn off. s'éteint.
Wait, Attendre,
WAIT FLASH
RAPIDLY The BLUE LED will flash La DEL BLEU clignotera
rapidly. rapidement.
11
PRESS - HOLD
x1
PRESS OFF
Press and hold the Appuyez et gardez enfoncé
le bouton de programmation.
programming button.
Wait, Attendez,
WAIT
3 SEC. The RED LED will turn ON. La DEL ROUGE s'allume.
ON
KEY BYPASS PROGRAMMING PROCEDURE 3/4 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 3/4
12
1
13
Wait, Attendez,
Wait for the RED and YELLOW Attendez que les DELs ROUGE
LEDs to slowly alternate. et JAUNE alternent doucement.
1
14
x1
PRESS
Press the Push-to-Start Appuyez 1 fois sur le
OFF button once to turn off the bouton démarrage (Push-
ignition. to-Start) pour éteindre
l'ignition.
15
16
Microsoft Windows
Computer with
Internet connection*
Ordinateur Microsoft
Windows avec
connection Internet*
Use the tool: Utilisez l'outil:
FLASH LINK UPDATER* FLASH LINK MANAGER* FLASH LINK UPDATER or FLASH LINK UPDATER ou
OR SOFTWARE | PROGRAMME
FLASH LINK MOBILE FLASH LINK MOBILE
OU to visit the DCryptor menu. pour visiter le menu DCryptor.
Smartphone*
(Internet provider
charges *Parts required (not included) *Pièces requises (non incluses)
may apply)
Téléphone
Intelligent*
VEHICLE'S OBDII
CONNECTOR
(des frais du
fournisseur
CONNECTEUR OBDII
DU VÉHICULE FLASH LINK MOBILE* Internet peuvent
s’appliquer)
17
AFTER DCRYPTOR PROGRAMMING COMPLETED
Go back to the vehicle and reconnect the 4-Pin (Data-Link)
EVO-ALL
connector and after, all the remaining connector.
KEY BYPASS PROGRAMMING PROCEDURE 4/4 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 4/4
NOTE NOTE
IF PROGRAMMING IS INTERRUPTED DURING SI LA PROGRAMMATION EST INTERROMPUE
THE PROCESS, SUCH AS A MODULE IS DURANT SON PROCESSUS, COMME PAR UN
DISCONNECTED OR BY TURNING OFF THE DÉBRANCHEMENT DU MODULE OU PAR LA
IGNITION WITH THE KEY, IT IS POSSIBLE THAT FERMETURE DE LA CLÉ DE CONTACT, IL EST
THE VEHICLE WILL NO LONGER START POSSIBLE QUE LE VÉHICULE NE PUISSE PLUS
NORMALLY, YOU MUST DISCONNECT AND DÉMARRER NORMALEMENT, VOUS DEVREZ
RECONNECT THE VEHICLE BATTERY TO DÉBRANCHER ET REBRANCHER LA BATTERIE
CORRECT THE SITUATION. DU VÉHICULE POUR CORRIGER LA SITUATION.
1
18
1
19
1
20
START UNLOCK
All doors must Remote start Unlock the doors with either: Enter the vehicle The vehicle can
be closed. the vehicle. • The OEM remote with the Intelligent now be put in to
• The remote-starter remote or SmartKey. gear and driven.
• The door handle
Toutes les Démarrez à Vous êtes
portes doivent distance. Entrez dans le maintenant prêt à
être fermées Déverrouillez les portes
avec soit: véhicule avec la embrayer et
• la télécommande d'origine, clé intelligente prendre la route.
• la télécomande du (SmartKey) sur
démarreur à distance ou
.• la poignée de la porte vous
Page 9 / 9
ALL
Notice: Updated Firmware and Installation Guides
MODEL: EVO-ALL
Updated firmware and installation guides are posted on our web site on a regular
DATE:02/2019 basis. We recommend that you update this module to the latest firmware and
FORTIN.CA
download the latest installation guide(s) prior to the installation of this product.
SN: 000000 00000
MADE IN CANADA
Notice: Mise à jour microprogramme et Guides d’installations
© 2018 ALL RIGHTS RESERVED Des mises à jour du Firmware (microprogramme) et des guides d’installation
sont mis en ligne régulièrement. Vérifiez que vous avez bien la dernière version
Module label | Étiquette sur le module
logiciel et le dernier guide d’installation avant l’installation de ce produit.
WARNING
The information on this sheet is provided on an (as is) basis with no representation or warranty of accuracy whatsoever.
It is the sole responsibility of the installer to check and verify any circuit before connecting to it. Only a computer safe
logic probe or digital multimeter should be used. FORTIN ELECTRONIC SYSTEMS assumes absolutely no liability or
responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in every case
is the sole responsibility of the installer performing the work and FORTIN ELECTRONIC SYSTEMS assumes no liability
or responsibility whatsoever resulting from any type of installation, whether performed properly, improperly or any other
way. Neither the manufacturer or distributor of this module is responsible of damages of any kind indirectly or directly
caused by this module, except for the replacement of this module in case of manufacturing defects. This module must be
installed by qualified technician. The information supplied is a guide only. This instruction guide may change without
notice. Visit www.fortinbypass.com to get the latest version.
MISE EN GARDE
L’information de ce guide est fournie sur la base de représentation (telle quelle) sans aucune garantie de précision et
d’exactitude. Il est de la seule responsabilité de l’installateur de vérifier tous les fils et circuits avant d’effectuer les connexions.
Seuls une sonde logique ou un multimètre digital doivent être utilisés. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume
aucune responsabilité de l’exactitude de l’information fournie. L’installation (dans chaque cas) est la responsabilité de
l’installateur effectuant le travail. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume aucune responsabilité suite à
l’installation, que celle-ci soit bonne, mauvaise ou de n’importe autre type. Ni le manufacturier, ni le distributeur ne se
considèrent responsables des dommages causés ou ayant pu être causés, indirectement ou directement, par ce module,
excepté le remplacement de ce module en cas de défectuosité de fabrication. Ce module doit être installé par un technicien
qualifié. L’information fournie dans ce guide est une suggestion. Ce guide d’instruction peut faire l’objet de changement
sans préavis. Consultez le www.fortinbypass.com pour voir la plus récente version.
Copyright © 2006-2019, FORTIN AUTO RADIO INC ALL RIGHTS RESERVED PATENT PENDING
TECH SUPPORT
Tél: 514-255-HELP (4357)
1-877-336-7797
www.fortinbypass.com
ADDENDUM GUIDE
WEB UPDATE | MISE À JOUR INTERNET