Académique Documents
Professionnel Documents
Culture Documents
Vehicle functions supported in this diagram (functional if equipped) | Fonctions du véhicule supportées dans ce diagramme
(fonctionnelles si équipé)
AUX.1
Comfort Group
Foot-Brake Status
Hood Status*
Heated seats
Trunk Status
séparément)
Trunk (open)
Rear defrost
Door Status
Tachometer
Disarm
Unlock
wheel
VEHICLE YEARS
Lock
Arm
VEHICULES ANNÉES
VOLKSWAGEN
Golf 2015-2018 • • • • • • • • • • • • • • • • • •
UNIT OPTION
Program bypass option OPTION UNITE DESCRIPTION
IF THE VEHICLE IS NOT EQUIPPED
WITH FUNCTIONAL HOOD PIN: Hood trigger (Output Status).
NOTES
Vehicle’s equipped with Virtual Cluster, not Véhicule équipé d’un odomètre virtuel, non pris en charge pour
supported for the key bypass. le contournement de clé.
(+)IGNITION1 (+)IGNITION2
(+)KEY SENSE
(+)STARTER (+)12V
(~)CAN (~)CAN
1HIGH 1LOW
TRANSPONDER
(+) Parking
light
(-)CLUTCH (-)CLUTCH2
Parking
light
(+)FOOT BRAKE
GOLF
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 4 / 15
Yellow In A1
A1
Purple Out A2
A2
Purple/White Out A3
A3
Green Out A4
A4 CUT LOOP FOR AUTOMATIC
TRANSMISSION MODE.
White Out A5
A5
COUPEZ LA BOUCLE POUR LE
Orange Out A6
A6 MODE TRANSMISSION
Orange/Black Out A7
A7 AUTOMATIQUE.
Dk.Blue Out A8
A8
Red/Blue In A9
A9
(~) RX Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
HOOD PIN (-) Hood pin Pink/Black In A15
A15
C5 Brown
CONTACT CAPOT (+)ACCESSORY Purple/Yellow In/Out A16
A16
C4 Gray/Black CAN 1 LOW
Green/White In/Out A17
A17
C3 Gray CAN 1 HIGH
Green/Red In/Out A18
A18
C2 Orange/Brown CAN 2 LOW
White/Black Out A19
A19
C1 Orange/Green CAN 2 HIGH
(~) TX Lt.Blue In/Out A20
A20
(+)Ignition2 White Out E1
E1 D6 White/Red Parking Lights
Orange Out E2
E2 D5 White/Blue Parking Lights
(+)12V Red In E3
E3 D4 White/Green (+) Parking Lights
(-)Ground Black In E4
E4 D3 Yellow/Red (+)Foot Brake
(+)Ignition Pink In/Out E5
E5 D2 Yellow/Blue (+)12V
(+)Starter Yellow Out E6
E6 D1 Yellow/Green
D2
Fusible7.5AMP
7.5AMP Fuse
D6
Cut
CUT
D3 D5 D4 E3/D2 E6 A16 E5 E1 C3 C4 C2 C1
(+)FOOT (+)PARKING PARKING (+)STAR-
(+)KEY (+)IGNI- (+)IGNI- (~)CAN (~)CAN (~)CAN (~)CAN TRANS-
BRAKE LIGHTS LIGHTS (+)12V TER 1 LOW 2 LOW 2 HIGH PONDER
SENSE TION1 TION2 1 HIGH
Black/ Grey/Yellow Red/ Red/ Red/Black Violet/ Black/White Black/Green Orange/ Orange/ Orange/ Orange/ WIRE
GOLF
Red Gris/Jaune White Grey or Black/Red Red or Black or Black/Gray Green Brown Red
Brown Orange/ Orange/ Pin2
Noir/ Rouge/ Rouge/ Rouge/Noir Violet/ Noir/Blanc Noir/Vert Orange/ Orange/ Brun Rouge
Rouge Blanc Gris ou Noir/Rouge Rouge ou Noir ou Noir/Gris Vert Brun
12 11 10 9 8 7 6 5 4 3 2
or Red/White 1 2 3 4 5 6 7 8
1
ou Rouge/Blanc 1 2 3 4 5 6 7 8
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 9 10 11 12 13 14 15 16
62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38
9 10 11 12 13 14 15 16
73 72 71 70 69 68 67 66 65 64 63
1 2
5 4
Back view - Connector at Back view OBDII
White 73-Pin light Back view
Black 16 -Pin Front view Black 2-Pin
connector C switch - Back connector Vue de face
Vue de dos - View. 5 Electric Ignition
connector
Connecteur transponder
Module connector
C Blanc de Connecteur Vue de dos
73 pins 4 Vue de dos
des feux Connecteur Noir Connecteur Noir
VESCM above driver kick panel de de 16 pins de 2 pins
Module VESCM En haut stationnement Module électrique connecteur du
panneau latérale côté chauffeur - vue de dos. d'ignition transpondeur
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 5 / 15
(+)Ignition Yellow In A1
A1
Purple Out A2
A2
Purple/White Out A3
A3
Green Out A4
A4
(-) CLUTCH White Out A5
A5
Orange Out A6
A6
Orange/Black Out A7
A7
Dk.Blue Out A8
A8
Red/Blue In A9
A9
(~) RX Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
HOOD PIN (-) Hood pin Pink/Black In A15
A15
C5 Brown
(+)ACCESSORY
CONTACT CAPOT Purple/Yellow In/Out A16
A16
C4 Gray/Black CAN 1 LOW
(CUT) CLUTCH2 TO CONNECTOR Green/White In/Out A17
A17
C3 Gray CAN 1 HIGH
(CUT) CLUTCH2 TO VEHICLE Green/Red In/Out A18
A18
C2 Orange/Brown CAN 2 LOW
White/Black Out A19
A19
C1 Orange/Green CAN 2 HIGH
(~) TX Lt.Blue In/Out A20
A20
(+)Ignition2 White Out E1
E1 D6 White/Red Parking Lights
Orange Out E2
E2 D5 White/Blue Parking Lights
(+)12V Red In E3
E3 D4 White/Green (+) Parking Lights
(-)Ground Black In E4
E4 D3 Yellow/Red
(+)Ignition Pink In/Out E5
E5 D2 Yellow/Blue
(+)Starter Yellow Out E6
E6 D1 Yellow/Green
A18 D6 A1
Cut Cut
CUT
A5 D5 D4 E3/D2 E6 A16 A1/E5 E1 C3 C4 C2 C1
(-) (CUT) (+)PARKING PARKING (+)STAR-
(+)KEY (+)IGNI- (+)IGNI- (~)CAN (~)CAN (~)CAN (~)CAN TRANS-
LIGHTS LIGHTS (+)12V TER 1 LOW 2 LOW 2 HIGH PONDER
CLUTCH CLUTCH2 SENSE TION1 TION2 1 HIGH
Purple/ Red/ Grey/Yellow Red/ Red/ Red/Black Violet/ Black/White Black/Green Orange/ Orange/ Orange/ Orange/ WIRE
GOLF
White White Gris/Jaune White Grey or Black/Red Red or Black or Black/Gray Green Brown Red
Brown Orange/ Orange/ Pin2
Mauve/ Rouge/ Rouge/ Rouge/ Rouge/Noir Violet/ Noir/Blanc Noir/Vert Orange/ Orange/ Brun Rouge
Blanc Blanc Blanc Gris ou Noir/Rouge Rouge ou Noir ou Noir/Gris Vert Brun
or Red/White 1 2 3 4 5 6 7 8
ou Rouge/Blanc 1 2 3 4 5 6 7 8
9 10 11 12 13 14 15 16
9 10 11 12 13 14 15 16
5 4 3 2 1 1 2
6 5 4
Connector at Back view OBDII
Back view - Black 5-Pin light Back view
Black 16 -Pin Front view Black 2-Pin
connector - Back of clutch switch - Back connector Vue de face
Near firewall View. 5 Electric Ignition
connector
Vue de dos - Connecteur transponder
Module connector
Noir de 5 pins - Près du pare Connecteur Vue de dos
feu derrière 4 Vue de dos
l’embrayage
des feux 6 Connecteur Noir Connecteur Noir
de de 16 pins de 2 pins
stationnement Module électrique connecteur du
- vue de dos. d'ignition transpondeur
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 6 / 15
TB-VW - THAR-VW6 - AUTOMATIC TRANSMISSION WIRING CONNECTION | GUIDE DE BRANCHEMENTS TRANSMISSION AUTOMATIQUE
Yellow In A1
A1
Purple Out A2
A2
Purple/White Out A3
A3
Green Out A4
A4 CUT LOOP FOR AUTOMATIC
TRANSMISSION MODE.
White Out A5
A5
COUPEZ LA BOUCLE POUR LE
NOT CONNECTED
NE PAS BRANCHER
Orange Out A6
A6 MODE TRANSMISSION
Orange/Black Out A7
A7 AUTOMATIQUE.
Dk.Blue Out A8
A8
Red/Blue In A9
A9
Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
Pink/Black In A15
A15
C5 Brown
Purple/Yellow In/Out A16
A16
C4 Gray/Black
Green/White In/Out A17
A17
C3 Gray
Green/Red In/Out A18
A18
C2 Orange/Brown
White/Black Out A19
A19
C1 Orange/Green
Lt.Blue In/Out A20
A20
White Out E1
E1 D6 White/Red Parking Lights
Orange E2
Out E2 D5 White/Blue Parking Lights
NOT CONNECTED Red E3
In E3 D4 White/Green (+) Parking Lights
NE PAS BRANCHER Black In E4
E4 D3 Yellow/Red
(+)Ignition Pink In/Out E5
E5 D2 Yellow/Blue 6 PIN CONN.
Yellow E6
Out E6 D1 Yellow/Green
THAR-VW6
TB-VW
SOLD SEPARATELY
16 PIN
16 PIN BLACK CONN.
VENDU SÉPARÉMENT MALE T-HARNESS PLUG FEMALE T-HARNESS PLUG
CONNECTEUR MÂLE
DU T-HARNAIS 4 CONNECTEUR FEMELLE
DU T-HARNAIS
D6
Cut
2
D3 D5 D4
(+)FOOT (+)PARKING (+)12V T-HARNESS - HARNAIS EN T
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13
ISOLATE
NOT CONNECTED
62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 ---------------------
ISOLER
73 72 71 70 69 68 67 66 65 64 63 MALE VEHICLE NON BRANCHÉ
LT.GREY PLUG
CONNECTEUR MÂLE
DU VÉHICULE GRIS PÂLE
5 2
24 PIN
MALE T-HARNESS PLUG
CONNECTEUR MÂLE
21 PIN BLACK CONN.
FEMALE T-HARNESS PLUG
1
DU T-HARNAIS CONNECTEUR FEMELLE
TB-VW - THAR-VW6 - MANUAL TRANSMISSION WIRING CONNECTION | GUIDE DE BRANCHEMENTS TRANSMISSION MANUELLE
Yellow In A1
A1
NOT CONNECTED Purple Out A2
A2
NE PAS BRANCHER
Purple/White Out A3
A3
Green Out A4
A4
(-) CLUTCH White Out A5
A5 NOT CONNECTED
Orange Out A6
A6 NE PAS BRANCHER
Orange/Black Out A7
A7
Dk.Blue Out A8
A8
Red/Blue In A9
A9
Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
Pink/Black In A15
A15
C5 Brown
Purple/Yellow In/Out A16
A16
C4 Gray/Black
(CUT) CLUTCH2 TO CONNECTOR Green/White In/Out A17
A17
C3 Gray
(CUT) CLUTCH2 TO VEHICLE Green/Red In/Out A18
A18
C2 Orange/Brown
White/Black Out A19
A19
C1 Orange/Green
Lt.Blue In/Out A20
A20
White Out E1
E1 D6 White/Red Parking Lights
Orange E2
Out E2 D5 White/Blue Parking Lights
Red E3
In E3 D4 White/Green (+) Parking Lights
Black In E4
E4 D3 Yellow/Red
1A Diode
(+)Ignition Pink In/Out E5
E5 D2 Yellow/Blue 6 PIN CONN.
Yellow E6
Out E6 D1 Yellow/Green
E5
NOT CONNECTED
NE PAS BRANCHER
E1
CUT
ISOLATE
NOT CONNECTED
---------------------
Yellow | Jaune IGNITION
ISOLER
NON BRANCHÉ
Yellow/Red | Jaune/Rouge
ISOLATE Black | Noir PTS OUT
NOT CONNECTED
---------------------
ISOLER
Black | Noir PTS OUT
NON BRANCHÉ
T-HARNESS - HARNAIS EN T
THAR-VW6
TB-VW
SOLD SEPARATELY
16 PIN
16 PIN BLACK CONN.
VENDU SÉPARÉMENT MALE T-HARNESS PLUG FEMALE T-HARNESS PLUG
CONNECTEUR MÂLE
DU T-HARNAIS 4 CONNECTEUR FEMELLE
DU T-HARNAIS
A18 D6
Cut
Cut
2
A5 D5 D4
(-) (CUT) (+)PARKING (+)12V T-HARNESS - HARNAIS EN T
Grey/Yellow Red/White
MALE
T-HARNESS OBDII
Purple/ Red/ Rouge/Blanc PLUG
connector
Gris/Jaune CONNECTEUR 16 PIN 16 PIN BLACK CONN.
White White FEMALE
T-HARNESS PLUG MÂLE DU Front view MALE T-HARNESS PLUG
CONNECTEUR MÂLE FEMALE T-HARNESS PLUG
Mauve/ Rouge/
T-HARNAIS
CONNECTEUR
FEMELLE Connecteur DU T-HARNAIS CONNECTEUR FEMELLE
DU T-HARNAIS
Blanc Blanc DU T-HARNAIS
OBDII
Vue de face
ISOLATE
NOT CONNECTED
---------------------
ISOLER
MALE VEHICLE NON BRANCHÉ
5 4 3 2 1 LT.GREY PLUG
CONNECTEUR MÂLE
DU VÉHICULE GRIS PÂLE
5 2
24 PIN
MALE T-HARNESS PLUG
CONNECTEUR MÂLE
21 PIN BLACK CONN.
FEMALE T-HARNESS PLUG
1
CONNECTEUR FEMELLE
6
DU T-HARNAIS
Connector at DU T-HARNAIS
light
Back view - Black 5-Pin switch - Back
View.
connector - Back of clutch
Near firewall
5 2
Vue de dos - Connecteur Connecteur 3 1
Noir de 5 pins - Près du pare
feu derrière
des feux
de 4 6
l’embrayage stationnement
- vue de dos. MALE VEHICLE BLUE PLUG
CONNECTEUR BLEU MÂLE
DU VÉHICULE
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 8 / 15
TB-VW - THAR-VW2 - AUTOMATIC TRANSMISSION WIRING CONNECTION | GUIDE DE BRANCHEMENTS TRANSMISSION AUTOMATIQUE
Yellow In A1
A1
Purple Out A2
A2 NOT CONNECTED
Purple/White Out A3
A3 NE PAS BRANCHER
Green Out A4
A4 CUT LOOP FOR AUTOMATIC
TRANSMISSION MODE.
White Out A5
A5 COUPEZ LA BOUCLE POUR LE
Orange Out A6
A6 MODE TRANSMISSION
Orange/Black Out A7 AUTOMATIQUE.
A7
Dk.Blue Out A8
A8
Red/Blue In A9
A9
Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
HOOD PIN (-) Hood pin Pink/Black In A15
A15
C5
C5 Brown
CONTACT CAPOT Purple/Yellow In/Out A16
A16
C4
C4 Gray/Black CAN 1 LOW
Green/White In/Out A17
A17
C3
C3 Gray CAN 1 HIGH
Green/Red In/Out A18
A18
C2
C2 Orange/Brown CAN 2 LOW
White/Black Out A19
A19
C1 Orange/Green CAN 2 HIGH
Lt.Blue In/Out A20
A20
White Out E1
E1 D6
D6 White/Red Parking Lights
Orange Out E2
E2 D5
D5 White/Blue Parking Lights
Red In E3
E3 D4
D4 White/Green (+) Parking Lights
NOT CONNECTED
NE PAS BRANCHER Black In E4
E4 D3
D3 Yellow/Red
(+)Ignition Pink In/Out E5
E5 D2
D2 Yellow/Blue
Yellow Out E6
E6 D1 Yellow/Green
ISOLATE
NOT CONNECTED
Yellow | Jaune IGNITION OUT ---------------------
ISOLER
NON BRANCHÉ
TB-VW White/Red
CUT
or Green
- TTHR-VW2
SOLD SEPARATELY D3 D5 D4 C1 C2
VENDU SÉPARÉMENT White/Green
or Green/Black TRANSPON- (+)FOOT (+) PARKING PARKING (~)CAN2 (~)CAN2
DO NOT EXTEND THE WIRES DER WIRE BRAKE LIGHTS LIGHTS HIGH LOW
EN T EN
(6 inches max).
Black/Red
GOLF
FEMALE T-HARNESS
(6 pouces max.) Noir/Rouge Gris/Jaune Rouge/Blanc Red Brown
IGNITION PLUG Orange/ Orange/
- HARNAIS
CONNECTEUR D’IGNITION
DU T-HARNAIS FEMELLE Rouge Brun
CONNECTEUR D’IGNITION
T-HARNESS
MÂLE DU T-HARNAIS
MALE T-HARNESS
12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5
IGNITION PLUG
T-HARNESS
1 2 3 4 5 6 7 8
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13
6 7 8 9 10
CONNECTEUR MÂLE 1 2 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38
9 10 11 12 13 14 15 16
MALE VEHICLE
IGNITION PLUG 73 66 63
72 71 70 69 68 67 65 64
5 Connector at light
D’IGNITION
DU VÉHICULE
TB-VW - THAR-VW2 - MANUAL TRANSMISSION WIRING CONNECTION | GUIDE DE BRANCHEMENTS TRANSMISSION MANUELLE
Yellow In A1
A1
Purple Out A2
A2 NOT CONNECTED
Purple/White Out A3
A3 NE PAS BRANCHER
Green Out A4
A4
(-) CLUTCH White Out A5
A5
Orange Out A6
A6
Orange/Black Out A7
A7
Dk.Blue Out A8
A8
Red/Blue In A9
A9
Lt.Blue/Black In/Out A10
A10
Black In A11
A11
Pink Out A12
A12
Yellow/Black Out A13
A13
Brown/White In A14
A14
HOOD PIN (-) Hood pin Pink/Black In A15
A15
C5
C5 Brown
CONTACT CAPOT Purple/Yellow In/Out A16
A16
C4
C4 Gray/Black CAN 1 LOW
(CUT) CLUTCH2 TO CONNECTOR Green/White In/Out A17
A17
C3
C3 Gray CAN 1 HIGH
(CUT) CLUTCH2 TO VEHICLE Green/Red In/Out A18
A18
C2
C2 Orange/Brown CAN 2 LOW
White/Black Out A19
A19
C1 Orange/Green CAN 2 HIGH
Lt.Blue In/Out A20
A20
White Out E1
E1 D6
D6 White/Red Parking Lights
Orange Out E2
E2 D5
D5 White/Blue Parking Lights
Red In E3
E3 D4
D4 White/Green (+) Parking Lights
Black In E4
E4 D3
D3 Yellow/Red
E5 1A Diode
(+)Ignition Pink In/Out E5
E5 D2
D2 Yellow/Blue
Yellow Out E6
E6 D1 Yellow/Green
E1 THAR-VW2
CUT
ISOLATE
NOT CONNECTED
Yellow | Jaune IGNITION OUT ---------------------
ISOLER
NON BRANCHÉ
ISOLATE
NOT CONNECTED
Yellow/Red | Jaune/Rouge BRAKE OUT ---------------------
ISOLER
NON BRANCHÉ
CONNECT ONLY IF BRAKE
MUST BE PRESSED TO START
BRANCHEZ SEULEMENT SI LE D6
FREIN DOIT ÊTRE APPUYÉ AU
DÉMARRAGE Cut Cut
- THR-VW2
TB-VW White/Red
CUT
or Green
- TTHR-VW2
SOLD SEPARATELY
D5 D4 C1 C2
VENDU SÉPARÉMENT White/Green
or Green/Black TRANSPON- (-) (CUT) (+) PARKING PARKING (~)CAN2 (~)CAN2
DO NOT EXTEND THE WIRES DER WIRE CLUTCH CLUTCH2 LIGHTS LIGHTS HIGH LOW
EN T EN
(6 inches max).
Purple/ Red/
GOLF
FEMALE T-HARNESS
(6 pouces max.) White White Gris/Jaune Rouge/Blanc Red Brown
IGNITION PLUG
Mauve/ Rouge/ Orange/ Orange/
- HARNAIS
CONNECTEUR D’IGNITION
DU T-HARNAIS FEMELLE
Blanc Blanc Rouge Brun
CONNECTEUR D’IGNITION
T-HARNESS
MÂLE DU T-HARNAIS
MALE T-HARNESS
1 2 3 4 5
IGNITION PLUG
T-HARNESS
1 2 3 4 5 6 7 8
6 7 8 9 10
CONNECTEUR MÂLE 1 2 9 10 11 12 13 14 15 16
MALE VEHICLE
IGNITION PLUG
5 4 3 2 1
5 Connector at light
D’IGNITION
DU VÉHICULE
1
WARNING: ATTENTION:
Close and open the Fermez et ouvrez la
driver door. porte conducteur.
1
2
Appuyez et maintenir le bouton
x1
Press and hold the
programming button: de programmation enfoncé:
D
C
B
H
à 6-broches.
E
A
F
G
(connecteur Noir)
B
HOLD
H
I
J
E
A
F
G
3
Release the programming Relâchez le bouton de program-
button when the Blue LED mation quand la DEL Bleue est
RELEASE is ON. allumée.
BLUE
D
ON
C
BLEU
B
H
I
J
If the LED is not solid BLUE Si la DEL Bleue n’est pas allumée,
E
D
disconnect the 6-Pin connector débranchez le harnais Principal à
C
A
B
H
F
I
G
J
(Main-Harness) 6-Broches et retournez au début
E
A
F
G
and go back to step1. de l'étape 1.
4
D
C
B
D
C
requis restants.
D
D
remaining harnesses.
B
C
C
E
H
B
B
H
H
I
J
A
I
I
J
J
F
G
E
E
E
A
A
A
F
G
F
F
G
G
TURN
ON/RUN
N
IG
Turn the key to the
ACC ON
CK
LO
PUSH
KEY BYPASS PROGRAMMING PROCEDURE 2/3 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 2/3
WITH
x1
T-HARNESS Press and release the Appuyez et relâchez le
THAR-VW6 programming button. bouton de programmation.
D
C
B
AVEC
H
PRESS
I
J
HARNAIS EN T The BLUE LED will turn OFF. La DEL BLEUE s'éteint.
E
THAR-VW6
A
F
G
The BLUE LED will La DEL BLEUE
OFF turn off. s'éteint.
H
J
D
C
I
Wait, Attendre,
The BLUE LED will flash La DEL BLEU clignotera
G
F
rapidly. rapidement.
7
PRESS - HOLD
x1 Appuyez et gardez enfoncé
D
OFF
B
H
I
PRESS
J
Wait, Attendez,
WAIT
3 SEC. The RED LED will turn ON. La DEL ROUGE s'allume.
ON
D
RELEASE
C
B
H
I
J
E
A
Relâchez le bouton de
F
button. programmation.
8
D
I
...
G
A
F
WAIT, The BLUE, RED and YELLOW Les DELs BLEUE, ROUGE
this processe may take up LEDs will rapidly alternate. et JAUNE alternent
to 5 minutes rapidement.
Attendez, ON OFF the RED LED to turn ON. La DEL ROUGE s'allume.
ce processus peut prendre
Wait, Attendez,
jusqu’à 5 minutes ON
ON ON
the YELLOW LED will flash La DEL JAUNE clignote
once. une fois.
1
9
Wait, Attendez,
H
J
D
I
Wait for the RED and YELLOW Attendez que les DELs ROUGE
G
A
F
F
OF
TURN Turn the key to the Tournez la clé à la
OFF
ACC ON
OFF position. position Arrêt (OFF).
CK
LO
START
PUSH
KEY BYPASS PROGRAMMING PROCEDURE 3/3 | PROCÉDURE DE PROGRAMMATION CONTOURNEMENT DE CLÉ 3/3
11
Disconnect all connectors and after the 6-Pin (Main-Harness)
D
C
I
D
C
B
C
B
B
or the 4-Pin Data-link connector.
H
H
I
J
I
J
E
D
C
E
B
A
H
F
F
G
I
J
Débranchez tous les connecteurs et ensuite le connecteur
E
6-pins (Connecteur principal) ou le connecteur
A
D
C
F
G
B
H
J
I
4-pins (Data-Link).
E
A
F
G
12
Microsoft Windows
Computer with
H
B
J
D
C
I
Internet connection*
Ordinateur Microsoft
G
A
F
Windows avec
connection Internet*
FLASH LINK UPDATER* FLASH LINK MANAGER* Use the tool: Utilisez l'outil:
OR SOFTWARE | PROGRAMME
FLASH LINK UPDATER or FLASH LINK UPDATER ou
OU FLASH LINK MOBILE FLASH LINK MOBILE
Smartphone* to visit the DCryptor menu. pour visitez le menu DCryptor.
(Internet provider
charges
may apply)
*Parts required (not included) *Pièces requises (non incluses)
H
B
J
D
C
I
Téléphone
Intelligent*
VEHICLE'S OBDII (des frais du
G
A
F
CONNECTOR
fournisseur
CONNECTEUR OBDII
DU VÉHICULE FLASH LINK MOBILE* Internet peuvent
s’appliquer)
13
AFTER DCRYPTOR PROGRAMMING COMPLETED
D
C
F
H
J
B
I
G
H
E
A
F
D
C
B
C
H
B
H
J I
E
E
A
F
G
14
Connect the TB-VW instead Branchez le TB-VW à la place
of the R-LINK. du R-LINK.
NOTE NOTE
IF PROGRAMMING IS INTERRUPTED DURING SI LA PROGRAMMATION EST INTERROMPUE
THE PROCESS, SUCH AS A MODULE IS DURANT SON PROCESSUS, COMME PAR UN
DISCONNECTED OR BY TURNING OFF THE DÉBRANCHEMENT DU MODULE OU PAR LA
IGNITION WITH THE KEY, IT IS POSSIBLE THAT FERMETURE DE LA CLÉ DE CONTACT, IL EST
THE VEHICLE WILL NO LONGER START POSSIBLE QUE LE VÉHICULE NE PUISSE PLUS
NORMALLY, YOU MUST DISCONNECT AND DÉMARRER NORMALEMENT, VOUS DEVREZ
RECONNECT THE VEHICLE BATTERY TO DÉBRANCHER ET REBRANCHER LA BATTERIE
CORRECT THE SITUATION. DU VÉHICULE POUR CORRIGER LA SITUATION.
MANUAL TRANSMISSION: READY MODE - TRANSMISSION MANUELLE: ACTIVATION MODE PRÊT À DÉMARRER
BY DEFAULT - PAR DÉFAUT
Start
ON
The vehicle Make sure that all Press the Engage the Release the Press the START button Remove the key Exit the vehicle Ready mode is now active,
must be doors are closed brake parking brake. brake for from the ignition and close all of remote start is functional.
running. and the pedal. pedal. 3 seconds. barrel : the vehicle the doors. The If one of the doors is open the
transmission is in The parking lights will will remain engine will stop mode will be disabled.
the NEUTRAL flash once and then running with the running once all
position. remain on. Remote-Starter. the doors are
closed.
Le moteur Assurez-vous que Appuyez sur Pendant que le Relâchez la Appuyer sur le bouton Retirez la clé de Sortez du véhicule Le mode prêt a démarrer est
est en toutes les portières la pédale moteur est en pédale de DÉMARRER durant contact du barillet et refermez toutes maintenant actif, le
marche. sont fermées et que de frein. marche, serrez frein. 3 secondes. : le moteur se les portières. Le démarrage à distance est
le levier de vitesse le frein de Les feux de stationnement maintiendra en moteur s’éteindra. fonctionnel.
est en position stationnement. clignoteront une fois puis marche. Si l'une des portière est
NEUTRE. resteront allumées. ouverte le mode sera
désactivé.
CHOICE 2 - CHOIX 2
Start
ON LOCK
The vehicle Make sure that Press the Engage the Release the Press the START Remove the key Exit the vehicle Lock the doors with Ready mode is now
must be all doors are brake parking brake. brake button for from the ignition and close all of the remote-starter active, remote start is
running. closed and the pedal. pedal. 3 seconds. barrel : the the doors. remote or the OEM functional.
transmission is The parking lights will vehicle will remote. The engine If one of the doors is
in the NEUTRAL flash once and then remain running will stop running. open the mode will be
position. remain on. with the disabled.
Remote-Starter. Déverrouillez les Le mode prêt a
Le moteur Assurez-vous Appuyez sur Pendant que le Relâchez la Appuyer sur le bouton portes avec la démarrer est
est en que toutes les la pédale moteur est en pédale de DÉMARRER durant Retirez la clé de Sortez du véhicule télécomande du maintenant actif, le
marche. portières sont de frein. marche, serrez frein. 3 secondes. contact du et refermez toutes démarreur à démarrage à distance
fermées et que le frein de Les feux de barillet : le les portières. distance ou la est fonctionnel.
le levier de stationnement. stationnement moteur se télécommande Si l'une des portière est
vitesse est en clignoteront une fois maintiendra en d'origine. Le moteur ouverte le mode sera
position puis resteront marche. s’éteindra. désactivé.
NEUTRE. allumées.
CHOICE 3 - CHOIX 3
ON
The vehicle Make sure that all Press the Engage the parking Release the Remove the key Exit the vehicle and Ready mode is now
must be doors are closed brake brake. brake from the ignition close all of the active, remote start is
running. and the pedal. pedal. barrel : the vehicle doors. The engine functional.
transmission is in will remain running will stop running If one of the doors is
the NEUTRAL with the once all the doors open the mode will be
position. Remote-Starter. are closed. disabled.
Sortez du véhicule Le mode prêt a démarrer
Le moteur Assurez-vous que Appuyez sur Pendant que le Relâchez la Retirez la clé de et refermez toutes est maintenant actif, le
est en toutes les portières la pédale moteur est en pédale de contact du barillet : les portières. Le démarrage à distance
marche. sont fermées et que de frein. marche, serrez le frein. le moteur se moteur s’éteindra. est fonctionnel.
le levier de vitesse frein de maintiendra en Si l'une des portière est
est en position stationnement. marche. ouverte le mode sera
NEUTRE. désactivé.
Start
TURN
UNLOCK ON/RUN
ON
All doors must Remote start the Unlock the doors with Insert and Turn Press The vehicle can
be closed. vehicle. the remote-starter the key to the the brake pedal. now be put in to
remote or the OEM Ignition ON/RUN gear and driven.
remote. position.
Toutes les Démarrez à Déverrouillez les portes Insérez et Appuyez Vous êtes
portes doivent distance. avec la télécomande du tournez la clé à
être fermées. sur la pédale de maintenant prêt à
démarreur à distance ou la position frein. embrayer et
la télécommande "ON/RUN". prendre la route.
d'origine.
This guide may change without notice. See www.fortin.ca for latest version.
Ce guide peut faire l’objet de changement sans préavis. Voir www.fortin.ca pour la récente version. Page 14 / 15
ONE
Notice: Updated Firmware and Installation Guides
MODEL: EVO-ONE
Updated firmware and installation guides are posted on our web site on a regular
DATE:02/2019
FORTIN.CA
basis. We recommend that you update this module to the latest firmware and
SN: 000000 00000
download the latest installation guide(s) prior to the installation of this product.
WARNING
The information on this sheet is provided on an (as is) basis with no representation or warranty of accuracy whatsoever.
It is the sole responsibility of the installer to check and verify any circuit before connecting to it. Only a computer safe
logic probe or digital multimeter should be used. FORTIN ELECTRONIC SYSTEMS assumes absolutely no liability or
responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in every case
is the sole responsibility of the installer performing the work and FORTIN ELECTRONIC SYSTEMS assumes no liability
or responsibility whatsoever resulting from any type of installation, whether performed properly, improperly or any other
way. Neither the manufacturer or distributor of this module is responsible of damages of any kind indirectly or directly
caused by this module, except for the replacement of this module in case of manufacturing defects. This module must be
installed by qualified technician. The information supplied is a guide only. This instruction guide may change without
notice. Visit www.fortinbypass.com to get the latest version.
MISE EN GARDE
L’information de ce guide est fournie sur la base de représentation (telle quelle) sans aucune garantie de précision et
d’exactitude. Il est de la seule responsabilité de l’installateur de vérifier tous les fils et circuits avant d’effectuer les connexions.
Seuls une sonde logique ou un multimètre digital doivent être utilisés. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume
aucune responsabilité de l’exactitude de l’information fournie. L’installation (dans chaque cas) est la responsabilité de
l’installateur effectuant le travail. FORTIN SYSTÈMES ÉLECTRONIQUES n’assume aucune responsabilité suite à
l’installation, que celle-ci soit bonne, mauvaise ou de n’importe autre type. Ni le manufacturier, ni le distributeur ne se
considèrent responsables des dommages causés ou ayant pu être causés, indirectement ou directement, par ce module,
excepté le remplacement de ce module en cas de défectuosité de fabrication. Ce module doit être installé par un technicien
qualifié. L’information fournie dans ce guide est une suggestion. Ce guide d’instruction peut faire l’objet de changement
sans préavis. Consultez le www.fortinbypass.com pour voir la plus récente version.
Copyright © 2006-2019, FORTIN AUTO RADIO INC ALL RIGHTS RESERVED PATENT PENDING
TECH SUPPORT
Tél: 514-255-HELP (4357)
1-877-336-7797
www.fortinbypass.com
ADDENDUM GUIDE
WEB UPDATE | MISE À JOUR INTERNET