Académique Documents
Professionnel Documents
Culture Documents
SYLLABUS:Module1,2,3
1. Explain the effect of coupling capacitors, by pass capacitors, load capacitors on single
stage MoSFETs amplifier for CS configuration
2. What do you mean low frequency response?
3. Find the value of Coupling Capacitor such that lower cut off frequency is a) 20 Hz b) 40
Hz
4. For the following circuit .Determine the corner frequency and maximum gain asymptote
of a MOSFET amplifier. Given parameters are: RS = 3.2 k , RD = 10 k , RL = 20 k , and
CL = 10 pF. The transistor parameters are: VT P = −2 V, K p = 0.25 mA/V2, and λ = 0.
17. For the MOSFET differential pair, assume Kn = 0.5 mA/V2 and IQ = 1 mA, Find forward
transconductance.
18.Draw the circuit diagram for dual input balanced output differential amplifier. Explain DC
characteristics, transfer characteristics, small signal (AC) analysis for differential mode gain &
common mode gain, common mode rejection ratio (CMRR) & input resistance /impedance
19.Explain differential amplifier with active load.
20.Explain the block diagram of a typical op-amp
21.Explain input offset voltage, Input offset current, input bias current, differential input
resistence, SVRR. State ideal and practical values.
22.Explain open loop configurations of opamp; Differential amplifier, Inverting amplifier, Non
inverting amplifier.
23.Explain Virtual Ground Concept.
24. Determine output voltage for Differential opmap:
Vin1 = 5 µV , Vin2 =-6 µV, A =200000,
25.Find output voltage for inverting opamp: Vin =20 m V DC, A= 200000